Razor DIRT ROCKET MX500 - Manual (Page 9)

repaIr anD MaInTenance
q chain and sprocket
The chain will typically have a “loose spot” and “tight spot” corresponding with a particular sprocket
rotational position. This is normal and common to all chain-driven products due to run-out tolerances of the
freewheel and sprocket. The chain should be adjusted to the ideal tension with chain in the tightest spot.
Proper chain alignment must be maintained. The wheel must not be skewed. If the chain is noisy or rough
running, check the lubrication, tension and alignment of the sprockets, in that order.
q Battery care and Disposal
Do not store the battery in temperatures above 75° F or below -10° F.
CONTAINS SEALED NON-SPILLABLE LEAD BATTERIES. BATTERIES MUST BE RECYCLED.
Disposal: Your Razor product uses sealed lead-acid batteries which must be recycled or disposed of in
an environmentally sound manner. Do not dispose of a lead-acid battery in a fire. The battery may explode
or leak. Do not dispose of a lead-acid battery in your regular household trash. The incineration, land filling
or mixing of sealed lead-acid batteries with household trash is prohibited by law in most areas. Return
exhausted batteries to a federal or state approved lead-acid battery recycler or a local seller of automotive
batteries. If you live in Florida or Minnesota, it is prohibited by law to throw away lead-acid batteries in the
municipal waste stream.
q charger
The charger supplied with the bike should be regularly examined for damage to the cord, plug,
enclosure and other parts and in the event of such damage, the Dirt Rocket must not be charged until it has
been repaired or replaced.
Use ONLY with the recommended charger.
q replacement parts
For a complete selection of replacement parts, visit www.razor.com.
q repair centers
For a list of authorized Razor repair centers:
• Check online at www.razor.com.
• Call 866-467-2967 for the center nearest you.
warnIng:
To avoid a pinch or injury, keep
fingers away from moving
sprockets and chain.
warnIng:
If a battery leak develops, avoid
contact with the leaking acid
and place the damaged battery
in a plastic bag. Refer to the
disposal instructions at left. If
acid comes into contact with
skin or eyes, flush with cool
water for at least 15 minutes
and contact a physician.
8
repaIr anD MaInTenance