Radio Shack XMODS 60-8506 - Manual (Page 2)

www.xmodsRC.com 2
3
Install the cone gear on the chassis’ drive shaft. Be sure to
align the shaft’s D-cut with the hole in the cone gear.
1
Loosen and remove the six screws in the rear upper deck.
6
Remove and discard the top shipping plate from the front
all-wheel drive steering assemblies and screw the front
upper deck back into place.
2
Remove the four screws in the rear lower deck and
then carefully lift and remove the rear axle assembly away
from the lower deck.
Rear Section All-Wheel Drive Installation
For longest life and optimum performance you must replace the rear differential with the all-wheel drive
differential; however, replacing the left and right suspension arms is not required.
4
Reassemble the rear section of your car in reverse order.
Reassemble the front and rear dampers and wheels.
5
Perform this step ONLY if your car will be driven indoors
exclusively, as the grease can collect dirt and dust!
Apply a dab of grease between the front bevel gears and
another dab between the rear bevel gears.
5
Insert the tie rod tips into the hole at the base of the left
and right turn knuckles. Screw the four front lower deck
screws into the all-wheel drive steering assemblies. Screw
the two turn knuckle screws into the front lower deck.
Note: Be sure the universal
joints have not disengaged
from the differential axles
before screwing the
assembly into place.
Long
screws
Exploded Front Drive Train View
Note: This view is provided
to assist you in assembling
the front drive train should
you need to reassemble it.
4
Discard the bottom shipping plate of the front all-wheel
drive steering assembly after unscrewing and removing all
bottom screws. Then, carefully place the steering assembly
on the front lower plate of the chassis.
CAUTION: KEEP GREASE OUT OF REACH OF SMALL CHILDREN.
Grease contains White Mineral Oil and Li-Ca complex soap. Avoid prolonged and/or repeated skin contact. May cause skin
irritation/dermatitis. Remove soiled or soaked clothing immediately.
FIRST AID
EYES: Flush with plenty of water. Call physician or poison center immediately.
SKIN: Wash with soap and plenty of water; apply skin cream. If irritation persists, get immediate medical attention.
INGESTION: If swallowed do not induce vomiting unless directed by a physician. Call physician or poison center immediately.
For Medical Emergencies, call Poison Center (303) 623-5716.
3
Carefully separate the rear axle at the differential and
replace it with the new rear differential gear.
Printed in China