Uniflame GAD1200B - Manual (Page 9)

Contact 1.800.762.1142 for assistance. Do not return to place of purchase.
PAGE NO
9
C 4URN CONTROL KNOB COUNTERCLOCKWISE TO ,/7 
D 2EMOVE LONG MATCHLONG BUTANE LIGHTER ONCE LIT
CAUTION: After Lighting - Using a shovel and heat resistant gloves,
carefully move the lava rocks back to their proper position, being
careful to avoid the flame.
 !FTER LIGHTING OBSERVE THE BURNER FLAME MAKE SURE ALL BURNER PORTS ARE LIT AND FLAME HEIGHT
MATCHES ILLUSTRATION &IGURE 
 !DJUST FLAME TO DESIRED HEIGHT WITH THE CONTROL KNOB
Caution: If burner flame goes out during operation, immediately turn
the control knob (OFF) and open lid to let the gas clear for 5 minutes
before re-lighting.
Turning Off
 4URN ,0 GAS TANK VALVE TO h#,/3%$v
 4URN ALL CONTROL KNOBS TO THE h/&& v POSITION
Note: ! hPOOFv SOUND IS NORMAL AS THE LAST OF THE ,0 GAS IS BURNED
 $ISCONNECT ,0 GAS TANK PER h$ISCONNECT ,0 'AS 4ANKv INSTRUCTIONS
Cleaning and Care
CAUTION:
1. All cleaning and maintenance should be done when outdoor
fireplace is cool and with the fuel supply disconnected.
2. DO NOT clean any outdoor fireplace part in a self cleaning oven. The
extreme heat will damage the finish.
3. Do not enlarge valve orifices or burner ports when cleaning the
valves or burners.
Notices
1. This outdoor fireplace should be thoroughly cleaned and inspected on a regular basis.
2. Abrasive cleaners will damage this product.
3. Never use oven cleaner to clean any part of outdoor fireplace.
Before Each Use:
 +EEP THE OUTDOOR FIREPLACE AREA CLEAN AND FREE FROM ANY COMBUSTIBLE MATERIALS GASOLINE AND
OTHER FLAMMABLE VAPORS AND LIQUIDS
 $O NOT OBSTRUCT THE FLOW OF THE COMBUSTION OF ,0 AND THE VENTILATION AIR
 +EEP THE VENTILATION OPENINGS OF THE ,0 GAS TANK AREA FREE AND CLEAR FROM DEBRIS
 6ISUALLY CHECK THE BURNER FLAMES TO MAKE SURE YOUR OUTDOOR FIREPLACE IS WORKING PROPERLY
 3EE SECTIONS BELOW FOR PROPER CLEANING INSTRUCTIONS
 #HECK ALL GAS CONNECTIONS FOR LEAKS
 #HECK COMPONENTS FOR ANY SIGNS OF DAMAGE OR RUST
 #HECK AND CLEAN THE BURNERVENTURI TUBES FOR INSECTS AND INSECT NESTS ! CLOGGED TUBE CAN
LEAD TO A FIRE BENEATH THE OUTDOOR FIREPLACE
 )F DAMAGE TO ANY COMPONENT IS DETECTED DO ./4 OPERATE UNTIL REPAIRS ARE EXECUTED
Cleaning Surfaces
 7IPE SURFACES CLEAN WITH MILD DISHWASHING DETERGENT OR BAKING SODA MIXED WITH WATER
 &OR STUBBORN SURFACES USE A CITRUS BASED DEGREASER AND A NYLON SCRUBBING BRUSH
 2INSE CLEAN WITH WATER
 !LLOW TO AIR DRY
Before Storing
 4URN CONTROL KNOB TO /&& AND ,0 GAS TANK VALVE TO h#,/3%$v
 #LEAN ALL SURFACES
 ,IGHTLY COAT THE BURNERS WITH COOKING OIL TO PREVENT EXCESS RUSTING
 )F STORING THE OUTDOOR FIREPLACE INDOORS DISCONNECT THE ,0 TANK SEE h$ISCONNECT ,0 'AS 4ANKv
SECTION AND LEAVE THE ,0 GAS TANK /54$//23
 0LACE THE PROTECTIVE CAP COVER ON THE ,0 TANK AND STORE THE TANK OUTDOORS IN A WELL VENTILATED
AREA OUT OF DIRECT SUNLIGHT
 #OVER OUTDOOR FIREPLACE WITH A DURABLE VINYL COVER DESIGNED TO FIT THIS UNIT
 3TORE IN A COOL AND DRY LOCATION AWAY FROM CHILDREN AND PETS
Checking for Leaks
WARNING: Before using this outdoor
fireplace, make sure you have read,
understand and are following all
information provided in the Dangers
and Warnings presented on page 2.
Failure to follow those instructions
can cause death, serious injury or
property damage.
Burner Connections
 -AKE SURE THE REGULATOR VALVE AND HOSE
connections are securely fastened to the burner
AND THE TANK
)F YOUR UNIT WAS ASSEMBLED FOR YOU VISUALLY CHECK
THE CONNECTION BETWEEN THE BURNER VENTURI PIPE
AND ORIFICE -AKE SURE THE BURNER VENTURI PIPE FITS
OVER THE ORIFICE
WARNING: Failure to inspect
this connection or follow these
instructions could cause a fire or an
explosion which can cause death,
serious bodily injury, or damage to
property.
 0LEASE REFER TO DIAGRAM FOR PROPER INSTALLATION
&IGURES  AND 
 )F THE BURNER PIPE DOES NOT REST FLUSH TO THE ORIFICE
PLEASE CONTACT  FOR ASSISTANCE
Tank/Gas Line Connection
 -AKE 
 OZ OF LEAK SOLUTION BY MIXING ONE PART
LIQUID DISHWASHING SOAP WITH THREE PARTS WATER
 -AKE SURE CONTROL KNOBS ARE h/&& v POSITION
&IGURE 
 #ONNECT ,0 GAS TANK PER h)NSTALLING ,0 'AS 4ANKv
SECTION
 4URN ,0 GAS TANK VALVE TO h/0%.v
 3POON SEVERAL DROPS OF SOLUTION OR USE SQUIRT
BOTTLE AT ALL h8v LOCATIONS &IGURES  AND  
A )F ANY BUBBLES APPEAR REMOVE THE ,0 GAS TANK
and reconnect, making sure the connection is
SECURE
B )F YOU CONTINUE TO SEE BUBBLES AFTER SEVERAL
ATTEMPTS REMOVE THE ,0 GAS TANK PER
h$ISCONNECT ,0 'AS 4ANKv INSTRUCTIONS AND
CONTACT  FOR ASSISTANCE
C )F NO BUBBLES APPEAR AFTER ONE MINUTE WIPE
AWAY SOLUTION AND PROCEED
Lighting
Caution: Keep outdoor gas cooking
appliance area clear and free from
combustible materials, gasoline and
other flammable vapors and liquids.
Caution: Do not obstruct the flow of
combustion and ventilation air.
Caution: Check and clean burner/
venturi tubes for insects and insect
nests. A clogged tube can lead to a fire beneath the grill.
Caution: Attempting to light the burner with the lid closed may cause
an explosion.
 -AKE SURE ALL LABELS PACKAGING AND PROTECTIVE FILMS HAVE BEEN REMOVED FROM THE OUTDOOR
FIREPLACE
 -AKE SURE THERE ARE NO OBSTRUCTIONS OF AIRFLOW TO THE BURNERS 3PIDERS AND INSECTS CAN NEST
WITHIN AND CLOG THE BURNER  VENTURI TUBE AT THE ORIFICE ! CLOGGED BURNER TUBE CAN LEAD TO A
FIRE BENEATH THE APPLIANCE
 #ONTROL KNOB MUST BE IN THE /&& POSITION &IGURE 
 #ONNECT ,0 GAS TANK PER h#ONNECT ,0 'AS 4ANKv INSTRUCTIONS
 4URN ,0 GAS TANK VALVE TO h/0%.v
 0USH AND TURN CONTROL KNOB TO ,/7 
 0RESS THE ELECTRONIC IGNITER BUTTON AND HOLD FOR UP TO  SECONDS TO LIGHT BURNER
 2ELEASE CONTROL KNOB AFTER  SECONDS
 )F IGNITION DOES NOT OCCUR IN  SECONDS TURN BURNER CONTROL KNOB /&& WAIT  MINUTES
AND REPEAT LIGHTING PROCEDURE
 )F IGNITER DOES NOT LIGHT BURNER
A #LEAR SMALL AREA OF LAVA ROCKS AWAY FROM THE BURNER
B 7EARING HEAT REISTANT GLOVES POSITION A LIT LONG MATCH OR LONG LIT BUTANE LIGHTER NEAR
THE SIDE OF THE BURNER
Operating Instructions
Figure 1
,0 'AS 6ALVE
WITH /RIlCE
LP Gas
Connection
Figure 2
X
X
X
X X
Figure 3
OFF
Figure 4
K
F
AA
Figure 5