Nemco Food Equipment Open-View Merchandsiers - Operations Manual - Manual (Page 2)

NEMCO FOOD EQUIPMENT 301 Meuse Argonne, Hicksville, OH 43526
1-800-782-6761 T oll Free 419-542-6690 Fax
www.nemcofoodequip.com 11-14-13
2
CLEANING
NOTE:
Proper maintenance plays an important part in the life span and functioning of the unit.
1. Turn the temperature control to the off position.
2. Turn the light switch and heat switch off.
3. Unplug the unit from the power supply.
4. Do not attempt to clean unit while it is turned on; it will be hot during operation.
5. The rotary rack is removed by lifting on the drive coupling located at the top of the shelf system and carefully removing the rack
from the interior of the case. Stationary racks just lift out. Wash with warm water and a mild detergent. Rinse and dry. Rack can
be installed by reversing process.
6. Clean daily. Clean excess food debris from the interior of the unit.
7. Clean the water reservoir daily with a scouring pad and mild detergent. Use of distilled water in the reservoir will reduce mineral
deposit build-up.
8. Clean interior and exterior of unit with a mild detergent and warm water. Be sure to dry unit.
9. Do not immerse in water or other liquid. Avoid splashing water into the motor unit.
SERVICE INSTRUCTIONS
1. For warranty or service information, please refer to the attached “Nemco Food Equipment Warranty Service Procedures.”
2. The light can be replaced easily in the event it burns out. Be sure to replace it with a shatterproof light.
ITEM
NUMBER
PART NUMBER DESCRIPTION
1 69164
48626-PM
48626-PT
48626-PR
CONTROL COVER, ALL
CONTROL COVER LABEL, 6421 / 6422
CONTROL COVER LABEL, 6425
CONTROL COVER LABEL, 6423
2 47472
46356
SOCKET
LAMP
3 47716 KNOB
4 47420 ROCKER SWITCH
5 48620 DOOR GLASS
6 45768-3 MOTOR
7 48621-PM
48621-HT
48621-PR
48623
FRONT BACKLIT GRAPHICS, 6421 / 6422
FRONT BACKLIT GRAPHICS, 6425
FRONT BACKLIT GPAPHICS, 6423
FRONT GRAPHICS SUPPORT
8 48268
48269
BACKLIT SOCKET
BACKLIT LAMP
9 48622-PM
48622-HT
48622-PR
48624
SIDE BACKLIT GRAPHICS, 6421 / 6422
SIDE BACKLIT GRAPHICS, 6425
SIDE BACKLIT GRAPHICS, 6423
SIDE GRAPHICS SUPPORT
10 66790-1
66791-1
66793
66794
RACK, 6421
RACK, 6422
RACK, 6425
RACK, 6423
11 69036 PAN COVER
12 48605 ADJUSTABLE LEG
NOTE THAT THERE MUST
BE AN 18” NON-COMBUSTIBLE
ZONE ON ALL (4) SIDES & A 40”
NON-COMBUSTIBLE ZONE
FROM THE TOP