Xylem 9100 Series Base Mounted Centrifugal Fire Pumps AC8585 REV.C - Manual (Page 4)

SAFETY INSTRUCTIONS
SAFETY
INSTRUCTIONS
This safety alert symbol will be used in this manual
and on the pump safety instruction decals to draw
attention to safety related instructions. When used
the safety alert symbol means ATTENTION!
BECOME ALERT! YOUR SAFETY IS INVOLVED!
FAILURE TO FOLLOW THE INSTRUCTIONS
MAY RESULT IN A SAFETY HAZARD.
Your 9100 Series Centrifugal Fire Pump should
have the following safety instruction decals
displayed. If the decals are missing or illegible
contact your local AC Fire Pump Systems
representative for a replacement.
Additional Safety Requirements:
1. Electrical connections to be made by
qualified Electrician in accordance with all
national, state and local codes.
2. Motor must have properly sized starter
with properly sized heaters to provide
overload and undervoltage protection.
3. If pump, motor or piping are operating at
extremely high or low temperatures,
guarding or insulation is required.
4. The maximum working pressure of the
pump is listed on the pump nameplate, do
not exceed this pressure.
RATING PLATE
WARNING
ROTATING COMPONENTS
DISCONNECT AND LOCKOUT
POWER BEFORE SERVICING.
DO NOT OPERATE WITHOUT
ALL GUARDS IN PLACE.
CONSULT INSTALLATION
AND SERVICE INSTRUCTION
SHEET BEFORE OPERATING
OR SERVICING.
FAILURE TO FOLLOW
INSTRUCTIONS COULD
RESULT IN INJURY
OR DEATH.
CAUTION CAUTION WARNING
COUPLER ALIGNMENT IS
REQUIRED! LEVEL AND
GROUT PUMP BEFORE USE!
CHECK ALIGNMENT BEFORE
GROUTING, AFTER SYSTEM
IS FILLED, AFTER SERVICING
PUMP, AND AS REQUIRED.
CONSULT THE SERVICE
INSTRUCTIONS FOR DETAILS.
FAILURE TO FOLLOW THESE
INSTRUCTIONS COULD
RESULT IN INJURY OR
PROPERTY DAMAGE.
DO NOT RUN PUMP DRY,
SEAL DAMAGE MAY OCCUR.
INSPECT PUMP SEAL
REGULARKY FOR LEAKS,
REPLACE AS REQUIRED.
FOR LUBRICATION
REQUIREMENTS, CONSULT
SERVICE INSTRUCTIONS.
FAILURE TO FOLLOW
INSTRUCTIONS COULD
RESULT IN INJURY OR
PROPERTY DAMAGE.
EYEBOLTS OR LIFTING
LUGS IF PROVIDED ARE
FOR LIFTING ONLY THE
COMPONENTS TO WHICH
THEY ARE ATTACHED.
FAILURE TO FOLLOW
INSTRUCTIONS COULD
RESULT IN INJURY
OR DEATH.
FIGURE 2 – SAFETY INSTRUCTION DECALS
4