Pump Solutions Group Neptune Polymaster - Manual (Page 4)

Standard Automatic Units
The following models may be specified with any electronic metering
pump from the chart below. Note: only electronic metering pumps
may be used with standard units. Motor-operated diaphragm pumps,
gear pumps or progressing cavity pumps must be used with remote
units (see chart on opposite page).
Polymaster ™
Standard Models Selection Chart
Model Number Capacity Max. Pressure
104717A 1.9 lph (0.5 gph) 9.7 bar (141 psi)
104718A 3.8 lph (1 gph) 7.6 bar (110 psi)
104719A 7.6 lph (2 gph) 3.4 bar (49 psi)
107804A 17 lph (4.5 gph) 3.4 bar (49 psi)
107805A 30.3 lph (8 gph) 4.1 bar (60 psi)
Model Number Capacity Max. Pressure
104717M 1.9 lph (0.5 gph) 9.7 bar (141 psi)
104718M 3.8 lph (1 gph) 7.6 bar (110 psi)
104719M 7.6 lph (2 gph) 3.4 bar (49 psi)
107804M 17 lph (4.5 gph) 3.4 bar (49 psi)
107805M 30.3 lph (8 gph) 4.1 bar (60 psi)
Electronic Metering Pumps
For Use With Automatic Polymasters ™
Manual Stroke Length Control • Automatic 4-20 mA Speed Control
Electronic Metering Pumps
For Use With Manual Polymasters ™
Manual Stroke Length Control • Manual Speed Control
Model
Number
Max Water Flow
A Polymer
Inlet
B Dilution
Water Inlet
C Mixed
Solution Outlet
PAD-60 227 lph (60 gph) 1 /2" FNPT 3 /4" FNPT 3 /4" FNPT
PAD-100 379 lph (100 gph) 1 /2" FNPT 3 /4" FNPT 3 /4" FNPT
PAD-200 757 lph (200 gph) 1 /2" FNPT 3 /4" FNPT 3 /4" FNPT
PAD-300 1,136 lph (300 gph) 1 /2" FNPT 3 /4" FNPT 3 /4" FNPT
PAD-600 2,271 lph (600 gph) 1 /2" FNPT 3 /4" FNPT 1" FNPT
PAD-1200 4,543 lph (1,200 gph) 1 /2" FNPT 1" FNPT 1 1 /2" FNPT
Model
Number
Max Water Flow
A Polymer
Inlet
B Dilution
Water Inlet
C Mixed
Solution Outlet
PMD-60 227 lph (60 gph) 1 /2" FNPT 3 /4" FNPT 3 /4" FNPT
PMD-100 379 lph (100 gph) 1 /2" FNPT 3 /4" FNPT 3 /4" FNPT
PMD-200 757 lph (200 gph) 1 /2" FNPT 3 /4" FNPT 3 /4" FNPT
PMD-300 1,136 lph (300 gph) 1 /2" FNPT 3 /4" FNPT 3 /4" FNPT
PMD-600 2,271 lph (600 gph) 1 /2" FNPT 3 /4" FNPT 1" FNPT
PMD-1200 4,543 lph (1,200 gph) 1 /2" FNPT 1" FNPT 1 1 /2" FNPT
4-20 mA Pump Control Manual Pump Control
1 Water Flow Meter w/Rate Set Valve
2 Gatlin Mixer
3 Polymer Pump*
4 Water Pressure Gauge
5 Water Pressure Switch
6 Water Solenoid Valve
7 Sector Switch, Main Power
8 Red Run Light
9 Amber Fault Light
10 Static Mixer
11 Junction Box Power & Signal
*Motor-Speed Control for Remote Pump Units All Models
1
9 8
7
1
10
6 4
5
11
A
B
C 2
3
55 cm
(21-5/8")
39 cm
(15-1/2")
56 cm
(22")
9 cm
(3-5/8")
12 cm
(4-3/4")
12 cm
(4-3/4")
45 cm
(17-3/4")
All Standard Models Models PAD/PMD-60
to PAD/PMD-1200
Standard Manual Units
The following models may be specified with any electronic metering
pump from the chart below. Note: only electronic metering pumps
may be used with standard units. Motor-operated diaphragm pumps,
gear pumps or progressing cavity pumps must be used with remote
units (see chart on opposite page).
All Models Except
Post Dilution
4