Prochem Blazer XL - Manual (Page 9)

86037390 02/14/07
2-2
DO NOT leave the vehicle engine running while operating this unit.
Dangerous Acid, Explosive Gases! Batteries contain sulfuric acid. To prevent acid burns, avoid contact with
skin, eyes and clothing. Batteries produce explosive hydrogen gas while being charged. To prevent a fire or
explosion, charge batteries only in well ventilated areas. Keep sparks, open flames, and other sources of ignition
away from the battery at all times. Keep batteries out of the reach of children. Remove all jewelry when servicing
batteries.
Before disconnecting the negative (-) ground cable, make sure all switches are OFF. If ON, a spark will occur at
the ground cable terminal which could cause an explosion if hydrogen gas or gasoline vapors are present. When
disconnecting the battery, ALWAYS disconnect the negative (-) terminal FIRST.
DO NOT smoke around the unit. Gas fumes may accumulate and be ignited. The battery is also extremely
flammable. This will prevent possible explosions.
DO NOT damage the vehicle in any manner during installation. When routing fuel lines DO NOT place the
hose in any location where damage may occur to the hose or vehicle. Avoid any contact with moving parts, areas
of high temperature, brake lines, fuel lines, muffler, catalytic converter, or sharp objects.
There is no fuel solenoid shut off on this unit. Use only the provided abrasion resistant fuel hose for fuel lines.
When traversing the vehicle floor with fuel lines, always use a bulkhead adapter. This will prevent leakage and
ensure that the hose is not punctured by vehicle vibration abrasion.
DO NOT exceed your vehicle's weight limit. The console with empty and accessories weighs approximately
710 lbs (800 lbs. if mounted on water tank). Make certain that the vehicle has the correct axle rating. This will
prevent unsafe vehicle driving conditions.
We require high-back seats on all vehicles in which units are to be installed for head and neck protection.
We recommend using a metal partition between the seats and equipment.
DO NOT operate this unit without the water supply attached and turned on. The water pump and other vital
components may be seriously damaged if this unit is permitted to operate dry without water.
Keep your vehicle work area clean. Wands, stair tools, and other accessories must be securely fastened before
driving the vehicle.
All high pressure hoses must be rated for 3000 PSI at 250°F. Thermoplastic hoses do not meet these
specifications and should not be used. Severe burns and injury may result if the hoses do not meet these
requirements.
The winterizing loop hose assembly, Part #86260700, PRV NO. 10-805380, is for winterizing use only. If
used improperly, live steam may escape from this hose, causing it to whip around. Burns or injury may result.
Make certain that you receive complete training by the distributor from whom you purchased this unit.
This unit uses high pressure and temperature. Improper or irresponsible use may result in serious injury.
Do not modify this unit in any manner. Improper modification can cause severe personal injury or fatality.
CALIFORNIA PROPOSITION 65 WARNING: Engine exhaust from this product contains chemicals known to the
State of California to cause cancer, birth defects, or other reproductive harm.