JLG 680S Parts Manual - Manual (Page 225)

3121235 680S 7-13
SECTION 7 ELECTRICAL
601D 1 Cable (Red) Options:
7016803 Prior to SN 0300138238
Not Required SN 0300138238 to Present (Part of Item 601A p/n 7027027)
601E 7016825 1 Cable (Black)
601F Not Required 1 Cable, Battery (Red)
602 to 603 Not Required 1
604 See Note AR Deutz Engine Harness Components (Note: Not Available at
Time of Printing)
604A 7027796 1 Deutz Engine Harness
604B See Note 1 Receptacle, Female - 25 Position (Note: Not Available -
Purchase Complete Harness)
604C 7027793 1 Plug-In, Connector
604D 1 Deutz Engine Harness Options (For other replacement parts
refer to Deutz engine dealer):
7027794 Tier II Engines (SN 0300085332 to SN 0300129454)
70001872 Tier III Engines (SN 0300129454 to Present)
605 to 607 Not Used
608 to 609 Not Required
610 See Note 1 Pump Harness (Note: Not Available for Purchase.)
610A 7007497 1 Plug (Pump End)
610B 7007498 1 Plug (Engine Harness End)
611 See Note 1 Controller Harness Assembly (Lift and Swing) (Note: Not
Available for Purchase.)
611A 7022819 1 Plug, Male - 8 Position (Natural)
4460871 8 Socket, Female
612 See Note 1 Controller Harness/Circuit Board Assembly (Drive and Steer)
(Note: Not Available for Purchase.)
612A 7022825 1 Plug, Male - 8 Position (Black)
4460871 7 Socket, Female
613 See Note 1 Controller Harness (Speed Control) (Note: Not Available for
Purchase.)
613A 4460224 1 Receptacle, Female - 6 Position
4460226 6 Socket, Female
614 4923379 1 Harness, Glowplug
615 See Note
616 Use 1001135114 2 Switch, Tilt Sensor (Includes Tilt Sensor) (was p/n 4360544)
616A 4460911 2 Plug, Male Deutsch - 3 Position
4460918 6 Socket, Female
4460912 2 Lock, Wedge
Ref OPTIONAL HARNESS COMPONENTS
701 to 702 Not Used
703 0257887 1 Alarm Harness (Includes Alarm)
0140032 1 Alarm
2820035 6in/15cm Loom
703A 4460424 1 Plug, Male - 2 Position
703B 4460268 2 Socket, Female
704 0272507 1 Strobe Light Harness Options (Includes Strobe Light):
704A 4460320 1 Connector, Female - 2 Position
4460267 2 Pin, Male
FIGURE 7-2. HARNESS COMPONENTS INSTALLATION (WITHOUT UGM) (CONTINUED)
ITEM # PART NUMBER QTY. DESCRIPTION REV.