JLG 510AJ Parts Manual - Manual (Page 236)

SECTION 7 - ELECTRICAL
236 510AJ 3121182
ITEM PART NUMBER QTY DESCRIPTION REV
469 3730125 1 Resistor, 120 OHM (Not Shown - Perkins Engine Only)
Ref GROUND CONTROL BOX WIRING DIAGRAM
4933171 Ref Deutz Engines Belgium Built Machines (Prior to SN
1300000981) 9-I
4933326 Ref Deutz Engines Belgium Built Machines (SN 1300000981
through 1300002604) F
4933384 Ref Deutz Engines Belgium Built Machines (SN 1300002605 to
Present) D
4933382 Ref Perkins Engines D
501 2920129 AR Bulb, Light
507 2400065 1 Fuse, 30Amp
508 2400066 1 Fuse, Holder
510 4460708 AR Receptacle, Female - 15 Position
510 4460226 AR Socket, Female
510 4922637 1 Harness, Jumper (Not Shown)
514 4460424 1 Connector - 2 Position (Belgium Built Machines) (SN
1300006701 to Present)
514 4460226 2 Socket, Female
518 4460894 1 Plug, Male - 6 Position (Deutz EMR2/Perkins Engines)
518 4460892 1 Receptacle, Female - 6 Position (Deutz EMR2/Perkins
Engines)
519 2902443 1 Receptacle Kit (Deutz EMR2/Perkins Only)
519 4461071 8 Socket, Female
519 4461072 1 Receptacle
519 4461073 1 Cap, Dust
519 4461074 1 Shell, Black
Ref STANDARD HARNESS COMPONENTS
601 2902060 1 Battery Cable Kit B
601A 7016817 1 Cable - Battery - to Starter Relay
601B 7027041 1 Cable - Battery + and Auxiliary Pump to Ground (was p/n
7016837)
601C 7016834 1 Cable - Starter Relay to Starter
601D 7016838 1 Cable - Starter Relay to Auxiliary Relay
601E 7016820 1 Cable - Auxiliary Relay to Auxiliary Pump
601E Not Required 0 Caterpillar/GM/Perkins Engines
602 Ref Harness Options:
602 1060904 1 Cable, Jumper (Perkins Engine Machines)
602 4922978 1 Harness, Start Assist Solenoid (Belgium Built Machines) (SN
1300000353 through 1300000979)
603 4922737 1 Engine Grounding Harness (Perkins Engine Machines)
604 1001099927 1 Perkins Throttle Actuator Harness (Includes Actuator)
604A 4460897 1 Receptacle, Female -2 Position (Perkins Engines Only)
604A 4460464 2 Pin, Male (Perkins Engines Only)
604A 2820018 AR Heatshrink
605 Ref Deutz EMR2 Engine Harness Components
605A 7027796 1 Deutz Engine Harness
605B See Note 1 Connector (Note: Not Available - Purchase Item 605A)
605C 7027793 1 Plug-In, Connector
605D 70000345 4 Glow Plug Harness (Includes Glow Plug) (Used on p/n 2000338
Engine Only) (Belgium Built Machines) (SN 1300001788 to
Present)
605E 7027794 1 Deutz Engine Harness (For other replacement parts refer to
Deutz engine dealer)
606 1001099926 1 Perkins Speed Sensor Harness (Includes Sensor)