Outdoor Great Room CNG-Traveler Gas Grill - Manual (Page 11)

The Outdoor GreatRoom Company • Cook Number Grill CNG-TRAVELER Gas Grill • Rev. A
11
If the grill fails to light properly:
1. Turn ignitor control knob to OFF. Wait at least five min-
utes for gas to clear, then retry.
2. Check gas supply and connections.
3. Repeat lighting procedure. If the grill still fails to op-
erate properly, turn ignitor control knob and OFF/ON
rocker switch to OFF, then check the following:
• Problem: Plugged orifice
Correction: Remove the LPG cylinder connection tube,
grate and grease drawer from the grill. Open the hood
and rotate the grill 90º until the control panel faces up.
Remove the four 5/16 inch hex nuts and spacers from
the underside of the control panel. Use a 3/4 open end
wrench to disconnect the 1/2 inch gas flex tube from
the back of the orifice. Lift the control panel off its four
studs and set it aside without removing the electrical
ignitor wire. Insert a thin 2-3 inch needle through the
back of the orifice to gently clear any obstructions.
Reinstall the control panel, and reconnect the gas flex
tube and reinstall all cooking components.
If an obstruction is suspected in the gas valve, please
call the gas grill dealer or gas appliance service person
for assistance.
• Problem: Misalignment of ignitor on burner
Correction: Check for proper position of the electrode
tip. The tip of the electrode should be pointing over
burner ports at the top of the burner. The gap between
the spark electrode and the burner should be 1/8 inch.
Adjust if necessary. Press and turn ignitor control knob
counterclockwise and check for presence of spark.
(See Figure 10).
• Problem: Disconnected Ignition Wires
Correction: Inspect the Ignitor junction box found be-
neath the Control Panel. Connect loose Ignitor wires to
the junction box and try to light the grill.
• Problem: Weak batteries
Correction: Replace “D” size batteries in ignitor mod-
ule underneath grill control panel.
4. If all checks or corrections have been made and the
grill still fails to operate properly, remove the LPG cyl-
inder from the grill and call the gas grill dealer or gas
appliance service person.
WARNING
Explosion Risk
Fire Risk
If a “FLASH-BACK” fire occurs in or around the
burner tubes:
• Turn the control knob and OFF/ON switch to
OFF position.
Disconnect the LPG cylinder from the grill.
•
• Once the grill has cooled down, clean the burn-
er tubes and burners according to the cleaning
instructions in this manual.
Failure to comply with these instructions could re-
sult in a fire or explosion which could cause serious
property damage, bodily injury or death.
Figure 10
Spark Electrode
Burner