Outdoor Great Room CNG-Traveler Gas Grill - Manual (Page 4)

The Outdoor GreatRoom Company • Cook Number Grill CNG-TRAVELER Gas Grill • Rev. A
4
Read These Safety Instructions
WARNING
Fire Risk
Explosion Risk
Failure to comply with these instructions could
result in a fire or explosion which could cause
property damage, serious bodily injury or death.
WARNING
Combustion by-products produced when using this
product contain chemicals known to the State of Cali-
fornia to cause cancer, birth defects, or other reproduc-
tive harm.
Grill Installation Codes
This grill has been tested in accordance with ANSI Z21.58-
2005/CSA 1.6-2005 and ANSI Z21.58a-2006/CSA1.6a-
2006. The installation of this gas grill must conform with lo-
cal codes or, in the absence of local codes with the National
Fuel Gas Code, ANSI Z223.1/NFPA54 (In the USA) or Nat-
ural Gas and Propane Installation Code, CSA B149.1 or
Propane Storage and Handling Code, B149.2 (in Canada).
Never use this gas grill in a garage, porch, shed, breeze-
way or any other enclosed area. The gas grill is to be used
outdoors only, with at least 6 inch clearance from the back
and sides of the grill to any combustible surface. The gas
grill shall not be located under overhead combustible con-
struction. Do not obstruct the flow of combustion or ven-
tilation air around the gas grill housing. Do not block the
bottom air vents.
This outdoor gas grill is not intended to be installed in or on
recreational vehicles and/or boats.
Correct LPG Cylinder Use
This gas grill is designed for use with a standard dispos-
able 1 lb. Liquid Propane Gas (LPG) cylinder, not included
with grill box. Never connect the gas grill to an LPG cylin-
der that exceeds this capacity. The LPG cylinder must be
an “OPD” gas cylinder which offers an Overfill Prevention
Device. This safety feature prevents the cylinder from be-
ing overfilled which can cause malfunction of the LPG cyl-
inder and/or grill.
The LPG cylinder must be constructed and marked in ac-
cordance with the Specifications for LP-Gas Cylinders of the
U.S. Department of Transportation (DOT) or the National
Standard of Canada, CAN/CSA-B339, Cylinders, Spheres
and Tubes for Transportation of Dangerous Goods: and
Commission, as applicable.
In addition:
1. The LPG cylinder must also be provided with a listed
overfilling prevention device, and a cylinder connec-
tion device compatible with the connection for outdoor
cooking appliances.
2. The LPG cylinder used must have a collar to protect the
cylinder valve.
3. The cylinder supply system must be arranged for vapor
withdrawal. See Figure 5 on page 9.
4. Never connect an unregulated LPG cylinder to the gas
grill.
5. Do not store a spare LP-gas cylinder under or near this
appliance or any other ignition source.
If this information is not followed exactly, a fire
causing death or serious injury may occur.
6. Always keep LPG cylinders in an upright position when
not in use.
7. Do not store (or use) combustible materials, gasoline or
other flammable vapors and liquids in the vicinity of this
gas grill.
8. Do not subject the LPG cylinder to excessive heat.
9. When the gas grill is not in use the LPG cylinder must
be disconnected from the grill.
10. Never store an LPG cylinder indoors. If storing the gas
grill in the garage or other indoor location, always dis-
connect and remove the LPG cylinder. Cylinders must
be stored outdoors out of the reach of children and
must not be stored in a building, garage or any other
enclosed area.