Glow-worm Heartbeat 4 - Manual (Page 9)

9 221905B
4.1 Unpacking
The carton contains the following:-
1. Fire assembly.
1. Ceramic fuel effect (In packaging inside firebox).
1. Fittings pack.
1. Gas feed pipe and fittings.
1. Literature pack.
1. Tool for window removal.
Remove all the items carefully to prevent damage. Some items
may be contained in the packaging fitments. Examine the
packaging carefully before discarding. Check that all the items
are present and undamaged.
4.2 Appliance Preparation
Stand the fire upright.
Remove the two transit screws securing the chassis to the fire
front located et the top rear of chassis and discard, see diagram
4.1.
Detach the window surround see diagram 6 "Instructions for
Use".
a) Remove the two knurled screws immediately below the
outer case canopy.
b) Lift the surround clear of the slots in the outer case apron.
Remove the control knob by pulling clear of the gas tap spindle.
Remove the control bezel by unscrewing two screws see
diagram 4.2.
Detach the outer case by removing the screws at the case sides
see diagram 4.2.
Pull the bottom of the case forwards while springing the bottom
corners outwards to clear the fixing brackets. Lift the case
upwards and forwards to clear . Place carefully to one side.
IMPORTANT : The front fascia of the case is secured by two
screws as shown in diagram 4.1a. These screws have been
tightened to avoid damage to the case during transit. These
screws must be slackened to enable the customer to
remove this section of the case.
Remove the glass panel assembly by turning the screws each
side of the frame
1 /
4
turn anticlockwise and lifting the unit clear
see diagram 6 Instructions for Use.
Remove the coal pack from the firebox and keep it safe.
4 Fire Front Preparation
Diagram 4.2
CONTROL
BEZEL
RETAINING
SCREW (2)
OUTER CASE
SECURING SCREW (2)
9495
Diagram 4.3
9640
GAS FIRE
FEED PIPE
UNION
NUT
GAS FIRE
SUPPLY
COCK
GAS FIRE
SUPPLY
COCK
CAP
RESTRICTOR
SCREW
WASHER
GAS
SERVICE
COCK
Diagram 4.1
9626
TRANSIT SCREWS
10171
WINDOW SURROUND REMOVAL Diagram 4.1A