Fire Magic Deluxe Classic Series 42,000 BTU - Manual (Page 8)

8 L-C2-017 REV 2 - 1406201000
Burner air shutters are accessed by removing the
front panel (face). The air shutters are located at the
end of the burners on the right side of the unit (see
page 2). The air shutter has a small dimple (see
Figure 6A), which allows it to lock into notches in
the burner face. This prevents the air shutter from
moving. Close the air shutters by turning the tabs
to a vertical position (Figure 6B). The air shutters
on Deluxe Barbecues can be adjusted by using the
match holder (provided with each unit - Figure 8, page
8). Place the ring over the air shutter tab and push
or pull to adjust the opening. Close the air shutters
with the tabs pointing up and down (Figure 6B). Light
your barbecue in accordance with the manual lighting
instructions found on page 8 and burn for 5 minutes
with the burners on 'HIGH' and the oven open.
Figure 6A & 6B - Air Shutter Adjustment Diagram
AIR SHUTTER ADJUSTMENT
After burning for 5 minutes, open the air shutters
until the fl ames lift off, or appear not to be touching
the burners. Then begin closing the air shutters until
the fl ames appear to burn while touching the burner
ports (Figure 6B). You may then see short yellow tips
on the fl ames. If fl ames are a lazy yellow, open the
air shutters until the fl ame is blue with yellow tipping.
ADJUSTING THE FLAME HEIGHT
The large knob on the face of the barbecue controls
the valve and adjusts fl ame height. The fi rst position
is 'HIGH', the second 'MEDIUM' and the fi nal 'LOW'.
fl ame height can also be set anywhere between
the High, Medium, and Low settings for all cooking
requirements and tastes.
Height of the fl ame with the valve in low position
may be regulated by means of a small adjusting
screw in the center of the valve stem. This screw is
accessible by removing the plastic valve knob which
pulls straight off the end of the valve stem.
PARTIALLY OPEN
FIGURE 6A
CLOSED
FIGURE 6B
IMPORTANT: This barbecue will not light and
will not heat evenly or cook properly unless the
air shutters are adjusted following installation
(reference "Air Shutter Adjustment", below).
BURNER ADJUSTMENT