Flowserve 035 000 Series - Manual (Page 8)

8
Flow Control Division
Kammer Control Valves
8 Trouble-shooting Chart
Fault Possible Cause Remedy
Stem motion 1. Packing excessively tightened 1. Tighten gland nut slightly more than „finger-tight“
impeded 2. Operating temperature too 2. Note operating data and contact dealer
high for selected trim
3. Supply pressure inadiquate
3. Check system for leaks in the supply pressure or signal lines. Re-
tighten the connections, if necessary replace leaky lines
4. Positioner defective 4. See operating instructions for positioner
Excessive 1. Bonnet loose 1. See step 7.2.6 for correct tightening of bonnet.
leakage 2. Worn or damaged 2. Re-machine or replace seat ring/plug.
seat ring/plug
3. Gaskets damaged
3. Replace gaskets
4. Inadiquate actuator thrust 4. Check air feed. If air feed is OK, contact dealer.
5. Plug incorrectly adjusted 5. Correctly adjust plug according to step 6.2.4
6. Incorrect direction of flow 6. Check specification. Contact dealer
7. Handwheel incorrectly 7. Adjust handwheel
adjusted (acts like end stop)
Inadiquate flow 1. Plug incorrectly adjusted 1. Correctly adjust plug according to step 6.2.4
(short stroke)
2. Positioner defective
2. See operating instructions for positioner
3. Operating requirements 3. Check operating data. Contact dealer
too high
Plug slams 1. Plug adjustment incorrect 1. Correctly adjust plug according to step 6.2.4
2. Inadiquate supply pressure 2. Check supply pressure, seal leaks, remove blockage
3. Trim too large for 3. Replace trim
flow rate
Regional Headquarters
Flowserve Flowserve Flowserve
Manderscheidtstr. 19 1350 N. Mt. Springs Prkwy. 12 Tuas Avenue 20
45141 Essen Springville, UT 84663
Germany USA Singapore 638824
Telephone: +49 (0) 201 8919 5 Telephone: +1 801 489 8611 Telephone: +65 862 3332
Facsimile: +49 (0) 201 8919 662 Facsimile: +1 801 489 3719 Facsimile: +65 862 4940
Main Sales Offices (Europa, Middle east, Africa)
Flowserve Flowserve Flowserve Flowserve
von-Braun-Straße 19a 12, av. du Québec Station Road Allee du Quartz 1
48681 Ahaus 91965, Courtaboeuf Cedex Pershore, Worcestershire CH-2300 La-Chaux-de Fonds
Germany France England WR102BZ Switzerland
Telephone: +49 (0) 2561 6860 Telephone: +33 (0) 1 60 923 251 Telephone: +44 (0) 1386 55 45 51 Telephone: +41 (0) 32 925 9700
Facsimile: +49 (0) 2561 68648 Facsimile: +33 (0) 1 60 923 299 Facsimile: +44 (0) 1386 55 49 68 Facsimile: +41 (0) 32 926 5422
Flowserve Flowserve
Cnr. Bismit and Granier Str. C/O Saleh & Abdulaziz Abahsain
Jet Park Ext 3 P.O. Box 209
Boksburg
1459 Gauteng
Al Khobar 31952
South Africa Saudi Arabia
Telephone: +27 397-3150 Telephone: 9663 857 3442
Facsimile: +27 397-5300/01/02 Facsimile: 9663 859 5284
All data subject to change without notice
©09.2003 Flowserve Corporation. Flowserve and Kämmer are trademarks of Flowserve Corporation