Allmand Brothers Allmand 7.5 FT BACKHOE - Manual (Page 6)

6
Safety of the operator was a
prime consideration in the design
of this backhoe. Proper shield-
ing convenient controls, simple
adjustments and other safety fea-
tures have been built into this
backhoe.
Accidents can be avoided if the following safety rules
are observed:
PREPARATION
Do not operate backhoe unless it is rigidly attached to
the tractor.
Know your controls. Read this operator’s manual and the
manual provided with your tractor. Learn how to stop the
tractor; the engine; and the backhoe quickly in an emer-
gency.
Provide adequate front end weight to counter balance
the backhoe at all times.
Be sure the area is clear of underground utilities or other
hazards.
Position a barricade around the work area.
Keep all bystanders a safe distance away.
OPERATION
Never allow anyone to operate the backhoe who is not
familiar with safe operating practices.
Do not attempt to enter operator’s platform by using sta-
bilizers as a step.
Operate from the backhoe operator’s seat only.
Allow only one person to operate the backhoe at a time.
Never dig with backhoe unless stabilizers are properly
set.
Do not dig under stabilizers or tractor with backhoe. Soft
ground or sandy soil can cause cave-ins.
Always swing bucket uphill to dump when on a hillside,
Keep loaded bucket low.
Set brakes and lock wheels when operating on hills and
banks to avoid dangerous run-away.
Watch for overhead wires. Do not touch wires with any
part of backhoe.
Never allow a person to work under a raised bucket.
Always lower bucket to ground when not digging.
Never leave tractor unattended with engine running.
TRANSPORTATION
Do not drive tractor near the edge of a ditch or excavation.
Always use accessory lights when transporting on a road or
highway to warn operators of other vehicles.
Check your local government regulations.
ADJUSTMENTS AND INSPECTION
Check hardware that attach backhoe to tractor and all pivot pins
for tightness several times daily. Replace any parts that are
bent, broken or missing.
Do not oil, grease or adjust backhoe while it is in motion.
Do not change any backhoe relief valve settings. They are fac-
tory set for best backhoe performance and safety.
CAUTION: Escaping hydraulic fluid under
pressure can penetrate skin causing serious
personal injury.
ƒ DO NOT use your hand to check for leaks. Use a piece of
cardboard or paper to search for leaks.
ƒ Stop engine and relieve pressure before connecting or dis-
connecting hydraulic lines.
ƒ Tighten all connections before starting engine or pressur-
izing lines.
ƒ
If any fluid is injected into skin, obtain medical attention
immediately or gangrene may result.
Be sure to relieve all pressure before disconnecting lines. Be
sure all connections are tight and that lines, pipes and hoses are
not damaged before applying pressure to the system.
Do not remove any guards on backhoe or tractor.
Do not use bucket as a battering ram.
Whenever you see this symbol It means: ATTENTION!
BECOME ALERT!
YOUR SAFETY IS INVOLVED!
SAFETY PRECAUTIONS