Maytag WINSLOW PI40 - Manual (Page 27)

7
Orange Sooty Flames - Glass turns Black
Possible Problem Solution
Burn pot is dirty Clean the burn pot
Vent pipe restricted Clean the vent pipe
Flue gas passageways restricted Clean the passageways
Combustion blower dirty Clean the combustion blower
Burning improper fuel Burn only wood pellet fuel or corn fuel that meets the fuel speci-
fications outlined on Page 5
Pellets not Feeding
Possible Problem Solution
Hopper empty Fill the hopper
Auger jammed Call service technician
Flue gas passageways restricted Call service technician
Auger motor not operating Call service technician
Winslow™ PI40 insert
Cat. No. Description
H6006 Adjustable Latch Pin
H3111 Ash Clean Out Cover, 2 Per Insert
H5886 Auger Motor
H5921 Auger w/lower Bearing
H5875 Blower Snap Switch
H5856 Cast Burn Pot
H5899 Clean-out Cover Gasket
H6019 Combustion Blower
H5900 Combustion Gasket Housing To Insert
H5903 Combustion Gasket Motor To Housing
H5917 Control Board Access Latch
H5978 Control Board
79020 Control Board Fuse 3 Amp, 5 Pack
H5888 Convection Blower
H5902 Convection Blower Gasket
Over Temperature Snap Switch Shuts Insert Down - Code - Ready light flashes red 2 long blinks
Possible Problem Solution
Convection blower not running Blower dirty, blower snap switch bad, or blower broken
Flue passageways or vent restricted Clean passageways or vent pipe (see Pages 20 and 21)
Snap switch* defective Replace the snap switch*
* Note: The snap switch has a reset button that must be pushed before insert will function (see Page 24).
REPLACEMENT PARTS
H5984 Decorative Nickel Bars / Upper Body
H3112 Door Handle Assembly
79040 Door w/glass (No Trim)
H6021 Flue Clean Out Box
H5988 Hardware Package
H5911 Hopper Door Wire
79021 Igniter Fuse 6 Amp, 5 Pack
H6005 Igniter W/hose Clamp
H5891 Overtemp Switch
H6004 Power Cord
H5887 Proof Of Fire Switch
H3128 Right Flange W/controls Access Door 40”
H6020 Right Flange W/controls Access Door 48”
H5898 Vacuum Line 12” Piece
H5889 Vacuum Switch
H5976 Wiring Harness
70K99 Touch-Up Paint, Black
Contact an Authorized Lennox Hearth Products dealer to obtain any of these parts. Never use substitute materials. Use of non-
approved parts can result in poor performance and safety hazards.