Banks Power 2001-2004 (LB7) Chevy_GMC 6.6L Duramax Turbo-Diesel Pickups - Manual (Page 13)

59.
On the factory air box assembly,
remove and retain the four Phillips
head screws and remove the air box
cover. Remove the original air filter
from the air box assembly.
60.
Install the Banks Ram-Air filter
making sure it seats properly in the
filter case and reinstall the top air
box cover. Reinstall the four (4)
Phillips head screws and verify
rubber air tube is installed on air box
assembly and throttle body.
61.
Affix the “Do Not Discard”
sticker onto the filter case.
-END, SEcTION 6-
Notification
The Banks Ram-AIr Filter
comes pre-oiled and
no oiling is necessary
for initial installation.
use Banks Ram-Air
FIlter cleaning system
(part#90094), available
from Gale Banks
engineering to service the
Ram-AIr FIlter. Follow the
instructions included with
the system to clean and
re-oil your Banks Ram-Air
Filter.
1.
Service Banks Ram Air Filter every
50-100,000 miles on street-driven
applications. Service more often in
off-road or heavy-dust conditions.
If an air-filter restriction gauge is
installed, then clean the element
when the air-filter restriction gauge
enters the restrictive red zone. See
Figure 11.
2.
Use Banks Ram Air Filter cleaning
system (part # 90094), available from
Gale Banks Engineering to service
the Air Filter. Follow the instructions
included with the cleaning system
to clean and re-oil your Banks Ram
Air Filter. No gasoline cleaning, No
steam cleaning, No caustic cleaning
solutions, No strong detergents, No
high pressure car wash, No parts
cleaning solvents. Any of these No’s
can cause harm to the cotton filter
media plus SHRINK and HARDEN the
rubber end caps.
CAuTIoN! extremely fine dust
from agriculture or off-road
use will pull the oil from the
element. Frequent re-oiling of
the element’s clean side might
be required. Completely service
when practicable. For extra
protection use an air-filter sealing
grease on rubber ends of the
element. Service only with Banks
Ram-Air-filter cleaner and Banks
Ram-Air-filter oil.
-END, SEcTION 7-
Section 7
FILTeR MAINTANCe
AIR-FILTER
RESTRICTION
GAUGE
RESTRICTIVE
RED ZONE
Figure 11 Typical air-filter restriction gauge
Section 6
BANKS RAM-AIR FILTeR INSTALLATIoN
96773 v.7.0
13