Camp Chef CCH4 - Manual (Page 3)

4 5
local fire department or dial 911.
Stay clear from flames. Do not
attempt to extinguish an oil or
grease fire with water.
22. Use only accessories, such as
cooking vessels recommended
by the manufacturer, to allow
safe and proper performance of
the product. Never use a cooking
vessel larger than the capacity
and diameter recommended by
the manufacturer.
23. This product is not intended for
commercial use.
24. Always allow the appliance to
cool before covering with the
patio cover.
25. Always cover the appliance, with
patio cover (if supplied), when
not in use.
26. In the event the appliance has
been exposed to water, tilt the
appliance forward and allow
water to drain from the burners
before attempting to ignite.
Installation Safety Precautions
• Use appliance only with LP
(propane) gas and the regulator/
valve assembly supplied.
• Installation must conform with
local codes, or in their absence
with National Fuel Gas Code,
NFPA 54/ANSI Z223.1. Handling
and storage of LP cylinders must
conform to LP Gas Code NFPA/
ANSI 58. Appliance is not for use
in or on recreational vehicle and/or
boats.
• Do not modify this appliance.
Modifications will result in a safety
hazard. Questions regarding
certification in other areas may be
addressed to 1-435-752-3922.
• Apartment Dwellers: Check
with management to learn the
requirements and fire codes for
using an LP Gas appliance at an
apartment. If allowed, use outside
on the ground floor with a 10 foot
clearance from walls or rails. Do
NOT use appliance on or under
any apartment, condominium
balcony or deck.
• Before opening LP tank valve,
check the coupling nut for
tightness. When appliance is not in
use, turn off control knob and LP
tank valve on supply cylinder.
• Never use LP tank if visibly rusted,
damaged, or out of date.
• If you notice grease or other hot
material dripping from appliance
onto valve, hose or regulator, turn
off gas supply at once. Determine
the cause, correct, clean and
inspect valve, hose and regulator
before continuing. Perform a leak
test.
• The regulator may make a
humming or whistling noise during
operation. This will not affect the
safety or use of appliance.
• Clean and inspect the hose before
each use of the appliance. If there
is evidence of abrasion, wear, cuts
or leaks, the hose must be replaced
prior to the appliance being put
into operation. See product sheet
for hose & regulator information.
• Do not block holes in bottom or
sides of appliance.
WARNING
Combustion by-products
produced when using this product
contain chemicals known to
the State of California to cause
cancer, birth defects, or other
reproductive harm.
• Never operate appliance with
LP tanks out of correct position
specified in Instructions.
• Always close LP tank valve and
remove coupling nut before
moving LP tank form specified
operating position.
• NEVER store a spare LP tank under
or near appliance or in enclosed
areas. NEVER fill the cylinder
beyond 80% full. An overfilled
spare LP tank is hazardous due
to possible gas released from the
safety relief valve. Failure to follow
these instructions exactly could
cause a fire resulting in death or
serious injury.
• If you see, smell, or hear escaping
gas, immediately get away from
the LP tank/appliance and call your
fire department.
• All spare LP tanks must have safety
caps installed on the LP tank outlet.
LP Tank Removal, Transport
and Storage
• Turn OFF all control knobs and
LP tank valve. Turn coupling nut
counterclockwise by hand only
– do not use tools to disconnect.
Install safety cap onto LP tank
valve. Always use cap and strap
supplied with valve. Failure to use
safety cap as directed may result
in serious personal injury and/or
property damage.
• A disconnected LP tank in storage
or being transported must have
a safety cap
installed (as
shown). Do not
store an LP tank
in enclosed
spaces such
as a carport
garage, porch, covered patio or
other building. Never leave an LP
tank inside a vehicle, which may
become overheated by the sun.
• Do not store LP tanks in an area
where children play.
• Storage of an appliance indoors is
permissible only if the cylinder is
disconnected and removed from
the appliance.
LP Tank
The LP tank used with your
appliance must meet the following
requirements:
• Purchase LP tanks only with these
required measurements: 12”
(30.5cm) (diameter) x 18” (45.7cm)
(tall) with 20 lb. (9 kg.) capacity
maximum.
• Be constructed and marked in
accordance with specifications for
LP tank of the U.S. Department
of Transportation (DOT) or the
National Standard of Canada, CAN/
CSA-B339, Cylinders, Spheres and
Tubes for the Transportation of
Dangerous Goods.
• The propane cylinder used with
this appliance must include a collar
to protect the cylinder valve.
LP tank valve must have:
• Type 1 outlet compatible with
regulator or appliance.
• Safety relief valve.
• UL listed Overfill Protection Device
(OPD). This OPD safety feature is
identified by a unique triangular
hand wheel. Use only tanks
safety cap
Install tank in
bottom tray
hole.