BoonDocker YAMAHA: Phazer - Manual (Page 16)

BoonDocker – 1585 Hollipark Dr. Idaho Falls, ID 83401 – 208-542-4411 / 877-522-7805
www.boondockers.com – email: [email protected] – fax: 208-524-7381
Revised 05-07-07 Page 16 of 16
LCD display is slow: Cold weather conditions can make the LCD respond very slowly. The Control Box will still
function OK. You can locate the box under the hood in order to provide heat so the LCD will
display quicker.
Moisture on LCD: Condensation is normal if the Control Box is quickly moved from a cold to a warm environment.
In some cases, the Control Box enclosure may no longer be sealing properly. If such problems
persist, contact Boondocker to determine if resealing the box is necessary.
Check Engine light: Make sure the wires in the EFI harness are correct and check for a bad connection in the wiring
harness. Recheck all connectors and be sure each is completely latched. Also inspect each wire to
make sure there are no frayed, broken, or melted wires. Look at the seals on the back of each
connector – if a pin has backed out, its wire seal will be protruding out of the connector more than
the rest.
X. Fuel Octane Recommendations
The octane your engine needs depends on many variables such as air density (elevation/temp), engine compression ratio,
camshaft timing, and ignition timing. The table below is provided as a general guideline only – your engine requirements
may be different.
Note: When using pump gas, be aware that the fuel quality can vary and has been known to be less than that shown on the
pump! We recommend you obtain fuel from a known source and/or mix with race gas if in doubt.
Boost Æ 8lbs 10lbs 12lbs 14lbs 16lbs
Comp.
Ratio Æ
11.8:1 9.0:1 11.8:1 9.0:1 11.8:1 9.0:1 11.8:1 9.0:1 11.8:1 9.0:1
0 ft 95 93 100 95 105 100 x x x x
2500 ft 93 92 98 94 103 98 108 103 x x
5000 ft 92 91 97 92 102 97 107 102 112 107
8000 ft 91 91 95 91 100 95 105 100 110 105
octane shown is determined by (R+M)/2
x = not recommended when using stock injectors and fuel pump
XI. Warranty, Terms & Conditions
Returned Goods – No merchandise will be accepted without prior approval. A RMA number (Return Merchandise
Authorization) provided by Boondocker is required before a return will be accepted. A 20% handling and restocking
charge will be applied to returned merchandise. No unauthorized returns will be accepted.
Limited Warranty – Boondocker warrants its product to the original purchaser against workmanship defects for a period
of 90 days, commencing from the date of product delivery to the Consumer.
Maximum Liability – The maximum liability of Boondocker in connection with this warranty shall not under any
circumstances exceed the price of the product claimed to be defective.