Smart Power Systems LR Series - Manual (Page 4)

Smart Power
®
Systems
A. C. MODULAR GENERATOR SYSTEM
Page 3 of 49
Never operate the system with leaks of any type. Clean up any hydraulic fluid that is
spilled or has leaked out of the system. Hydraulic fluid is combustible, and ignition may
occur.
With the exception of oil filter periodic replacement, never modify or remove any of the
components within the tray assembly.
Never modify or remove any of the components within the pump. This includes all fittings
that are originally provided with the A.C. modular generator system.
Never attempt any adjustments or repairs to the A.C. modular generator system while the
vehicle engine is running and the PTO is engaged.
Never operate the system with the hydraulic fluid exceeding 175
° F. Above this
temperature, hydraulic fluid can rapidly oxidize and deteriorate causing generator
performance problems. Operating the system while the hydraulic fluid is above 175
° F will
void the system’s warranty.
Hydraulic fluid is combustible and toxic. In the event of human contact with hydraulic fluid,
generously flush body part (eyes, skin, etc.) with running water. Avoid inhalation of any oil
mist or vapor. Do not ingest hydraulic fluid. In case of fire, use foam, dry chemical or
carbon dioxide to extinguish flame.
Do not exceed the wattage rating of the generator. The generator may be permanently
damaged and the generator and hydraulic components may reach temperatures that could
cause severe burns upon human contact with the components. Operating the generator
system at wattages above the system’s rating will void the system’s warranty.
Disengage the system immediately if a hydraulic fluid leak is detected. Operation of the
A.C. modular generator system with low fluid level will result in permanent damage to the
hydraulic components in the system and will void the system’s warranty.
Do not attempt to operate the generator with the tray assembly top lid open. Do not
tamper with the top lid interlock switch or the hydraulic fluid level sensor.
Never attempt to operate the system without hydraulic fluid. Always maintain a fluid level
between ½ to ¾ full in the sight gage. When installing the system, fill the hoses with
hydraulic fluid (Dexron III) before engaging the system. Failing to do so will void the
system’s warranty.
Operating the A.C. modular generator system in the presence of flammable vapors may
result in an explosion.
Use only hoses that meet or exceed the minimum requirements specified in this manual.
A ruptured hose can cause personal injury and/or damage to the generator system.