Carrier INFINITY 2020 - Manual (Page 2)

2
PERSONAL INJURY HAZARD
Failure to follow this caution may result in personal injury.
Ozone in concentrations above 0.05 PPM may be
hazardous to health.
Des concentrations d’ozone superieures a 0.05 PPM
peuvent etre nocives pour la sante.
CAUTION
!
APPLICATION CONSIDERATIONS
The Infinityt Air Purifier is designed for use in the return air
duct of a forced air heating, cooling, and ventilation system.
Models GAPABXCC1620, GAPABXCC2020 and
GAPABXCC2420 are specifically designed for use in systems
with a fan coil.
Air Conditioning
The Infinityt Air Purifier should be installed in a system so that
all the return air is circulated through the air purifier. It should be
located upstream of the fan coil This will help keep the fan coil
clean and prevent condensation from forming within the
Infinityt Air Purifier.
Humidifiers
An evaporative humidifier can be mounted upstream of the
Infinityt Air Purifier. It is best to install atomizing humidifiers
downstream of the air purifier because hard water salt deposits
and water droplets may damage the air purifier. If an atomizing
humidifier must be mounted upstream of the Infinityt Air
Purifier, it should be mounted as far upstream as possible (at least
6 ft. recommended), and a standard disposable furnace filter
should be mounted between the humidifier and the air purifier to
trap hard water salt deposits and water droplets.
Transitions
If the return air duct or fan coil openings do not fit the Infinityt
Air Purifier cabinet openings, gradual transitions are
recommended to reduce air turbulence and maximize efficiency.
No more than 20 degrees (about 4 in. per running ft.) of
expansion should be used on each side of the transition fitting.
Turning Vanes
If the Infinityt Air Purifier is installed adjacent to a 90 degree
duct elbow, turning vanes should be added inside duct to improve
air distribution across the face of the air purifier.
Electrical Power / Air Flow Sensor
The Infinityt Air Purifier should only be powered when airflow
is present. This model is designed for use with a fan coil and is
equipped with an air flow sensor which provides power only
when the fan coil blower is operating (See Fig. 2). Infinityt Air
Purifier models GAPABXCC1620, GAPABXCC2020, and
GAPABXCC2420 are designed to be powered from a 208/230
VAC power source.
A06387
Fig. 2 --- Air Flow Sensor
Door (x1) Cabinet (x1) Enhancement Module (x1) Safety Screen (x1)
Return Duct Adapters:
Long (x2) / Short (x2) Air Flow Sensor (x1)
(x1)
(x2)
(x3)
(x1)
(x2)
Installation Components
(in bag attached to power cord)
Installation Manual
1
GAPA Infinity Air Purifier Sizes 1620, 2020, & 2420
Installation, Start---up, and Operating Instructions
NOTE: Re adthe entire instructionm anualbefore startingthe install.
TABLE OF CONTENTS
Page SAFETY CO NSIDERATIO NS
1 . . . . . . . . . . . . . . . . . . . . . . . .
INTRODUC TION
2
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PLANNING
2--5
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Application
2
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . InstallationR equirements
2 . . . . . . . . . . . . . . . . . . . . . . . . . . DimensionsT able1
3
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Air Conditio ning
5
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Humidifiers
5
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
OutdoorAir
5
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
SheetMetalIn stallation
5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . Transitions
5
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . TurningVane s
5
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . SelectLocatio n
5
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Directionof A irflowthroug hAir Purifier 5 . . . . . . . . . . . . . . INSTALLATIO N
5--6
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Orientation
5--6
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Details
6
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . TypicalMoun tingPositions
6 . . . . . . . . . . . . . . . . . . . . . . . . . ElectricalInst allation
6
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . FurnaceApp lication
6
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . SYSTEM CH ECKOUT
7
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . MAINTENA NCE
7
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
ReplacingPu rifierCartrid ge 7 . . . . . . . . . . . . . . . . . . . . . . . .
TROUBLES HOOTING
7 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Recommen ded ServiceTools
7 . . . . . . . . . . . . . . . . . . . . . . . . Indicationof ElectricalTro uble 7 . . . . . . . . . . . . . . . . . . . . . . OTHERFAC TS YOU SH OULDKNO W 7 . . . . . . . . . . . . . . . Ozone
7
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . HighAltitud eOperation
7 . . . . . . . . . . . . . . . . . . . . . . . . . . . Specificatio ns Table2
8 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WARRANTY
9
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
A05265 Fig. 1 -- Unit GAPA SAFETY CO NSIDERATIO NS Improperin stallation,a djustment,a lteration,s ervice,
maintenanc e, or use canca use explosion , fire, electric alshock or othercond itionswhichm aycausepers onalinjuryorp roperty
damage.Co nsult a qualifi edinstaller, se rviceagency, or your
distributoro r branchfor informatio nor assistan ce.The qualifiedinst alleror agenc ymustusefac toryauthoriz edkitsor accessorie s whenmodif yingthis pro duct. Refe r to the
individualin structionspa ckagedwith the kits or a ccessories wheninstallin g. Followall saf ety codes. W ear safety glas ses and work gloves.
Use quenc hingclothfo r brazingop erations.H ave fire extinguishe r available. R eadthese ins tructionsthor oughlyand
follow all w arningor ca utionsattach edto the unit. Consult
localbuildin gcodesand N ationalElect ricalCode(N EC) for specialrequir ements . It is importa ntto recogn izesafetyinfo rmation.Th is is the safety--alertsy mbol . Whenyou seethissym bolontheun it
andin instru ctionsor man uals,be alert to the pote ntialfor
personalinju ry. Underst andthe sign al wordsDA NGER, WARNING, andCAUTIO N. Thesew ordsareuse dwith the
safety--alerts ymbol. DA NGER iden tifiesthe mo stserious hazardswhic hwill resulti n severeper sonalinjuryo r death. WARNING signifieshaz ardswhichc ould resultin personal
injuryor dea th. CAUTIO N is usedto identifyunsa fepractices
whichmay resultin pers onalinjuryor productand property damage.NO TE is usedto highlightsu ggestionswh ichwill resultin enha nced installation,re liability,or op eration.
Air Purification Cartridge (x1)
(x2)
A07111
Fig. 3 --- Infinityt Air Purifier Components
GAP
A
B