Vermont Casting ODGSR42A - Manual (Page 9)

9
ODGSR Series Outdoor Gas Fireplace
20007114
Operating Instructions
Log Installation
1. Remove logs from the packaging.
As with all plastic, these bags are not toys
and should always be kept away from chil-
dren and infants.
2. Place left rear log on rear log support.
Ensure that log is firmly positioned and there is no
side-to-side movement. (Figs. 11 & 12)
3. Carefully place Ember Log between grate and
burner. (Figs. 11 & 12)
4. Place the front of right rear log on the burner and the
back of the log on the rear log support.
5. Place the top logs onto the locator notches. Ensure
the logs are secure. (Fig. 11 & 12)
LG317
UVODSR36
logs
11/24/03 djt
Right Cross
Log
Left
Cross
Log
Left Rear
Log
Right
Rear
Log
Ember
Log
LG317
Fig. 11 ODGSR36 log placement.
First Firing
Upon completing the gas line connection, a small
amount of air will be trapped in the line. When first
lighting the unit with pilot light, it will take a few minutes
to purge the trapped air. Once purging is complete, the
pilot and burner will light and operate as indicated in the
instruction manual. Subsequent lightings of the appli-
ance will not require purging.
When lit for the first time, the appliance will emit a slight
odor for an hour or two. This is due to paint and lubri-
cants used in the manufacturing process. After each
lighting, vapor may condense and fog the glass; this
moisture disappears in a few minutes of burning.
Flame Adjustment
For units equipped with Hi/Lo valves, flame adjustment
is accomplished by rotating the Hi/Lo adjustment knob
located near the center of the gas control.
LO
HI
Turn
counterclockwise
to increase
flame height
Turn clockwise
to lower
flame height
FP390
FLAME ADJUSTMENT KNOB
11/21/96
Fig. 13 Flame adjustment knob for SIT820 valve.
Flame Characteristics
It is important to periodically perform a visual check of
the pilot and the burner flames. Compare them to the il-
lustrations below (Figs. 14, 15, 16). If any of the flames
appear abnormal call a service person.
LG318
ODUVSR42
log set
11/24/03 djt
Left Rear
Log
Left Cross
Log
Middle Cross Log
Right Cross
Log
Right Rear
Log
Log Left
Ember
Grate
Fig. 12 ODGSR42A log placement.
LG318
Log
Right
Ember