Engine tiller, Junior tiller, Specifications – Troy-Bilt 15009 User Manual
Page 51: Recommended maintenance intervals
Attention! The text in this document has been recognized automatically. To view the original document, you can use the "Original mode".
ENGINE
TILLER
Type—
Height—
Tecumseh; four-cycle, single-cylinder, air-
Without handlebars:......................................... 20
cooled, horizontal crankshaft, manual choke.
With handlebars in low position................
37
-
1
/
2
"
solid state electronic ignition.
With handlebars in high position...................47"
Horsepower—
Length—
4
With handlebars in low position.................
52-1/2"
Fuel Tank Capacity—
Without handlebars......................................... 45"
2 quarts.
Width
Fuel Requirements
—
Hood width................................................. 16-1/2"
Clean, fresh, lead-free, automotive gasoline
Tilling width...................................................... 14"
Engine Oil—
'^heel width................................................ 18-5/8"
API Service SF, SG, SH or SH/CC. SAE30W
at top of handlebars........................ 19-1/2"
above 32°F. Below 32°F use SAE 5W30
Weight
(SAE low is an acceptable substitute).
Recoil start model....................................149-lbs.
Do not use 10W40 motor oil.
Wheel and Tire Size
Engine Oil Capacity
3.25 x 5"; 15-to-20 psi (pounds / sq. inch)
21 ounces; however, always fill to the top of
Transmission
the oil fill tube.
Gear oil capacity: 3]^ pints (55-to-57 ozs.)
Spark Plug Type
Small Top-Offs: SAE 140, SAE 85W-140, or
Champion J-8 (or equivalent) or Autolite 356
SAE 80W-90 weight gear oil with an API rating
(or equivalent). Canadian models: RJ-17LM.
of either GL-4 or GL-5.
Spark Plug Gap
Replacement: SAE 140 or SAE 85W-140
030
inch.
weight gear oil with an API rating of GL-4 only.
JUNIOR TILLER
SPECIFICATIONS
RECOMMENDED MAINTENANCE INTERVALS
MAINTENANCE
PROCEDURE
Before
Each
Use
Every
10
Hours
Every
25
Hours
Every
30
Hours
Every
50
Hours
Check Engine Oil Level *
•
Clean Engine Cooling Fins
•
Check Bolts and Nuts **
•
Check Tension on Drive Belts **
•
Change Engine Oil ***
•
Oil and Grease Tiller
•
Service Air Cleaner Foam Pre-Cleaner(not on Junior)
•
Check Transmission Gear Oil Level **
•
Check Tines for Wear
•
Check Spark Plug
•
Replace Air Cleaner Paper Filter
t See schedule below for each engine
* Check oil level after every 5 operating hours.
** Check after first 2 hours of break-in operation.
*** Change more frequently in dusty or dirty conditions. (Change after first 2 hours of break-in operation.)
t 6HP Econo-Horse— Replace paper air filter every 100 hours,
t 5HP Pony Model— Replace paper air filter every 50 hours,
t 4HP Junior Model— Replace paper air filter every 25 hours.
49