E-Z-GO EXPRESS S4 HIGH OUTPUT - Manual (Page 22)

GENERAL SPECIFICATIONS
Read all of this manual to become thoroughly familiar with this vehicle. Pay particular attention to all Notices, Cautions, Warnings, and Dangers.
2 - 4
2
MODEL: EXPRESS L4
TYPE: ELECTRIC POWERED PERSONNEL CARRIER
MODEL YEAR: 2012
Part No:. 618863
TruCourse Technology: Programmable to multiple vehcle terrains, with expanded regenerative braking function, and vehicle charger lockout
Solid State continuously variable seperately excited speed controller Six, 8 Volt Deep Cycle Batteries
Dash mounted direction selector switch (Forward-Neutral-Reverse) Full torque, reduced speed reverse
Anti-roll back, walkaway braking and alarm Inductive throttle sensor
Programmable regenerative braking, acceleration and speed Handheld vehicle diagnostics and rounds tracking
Battery Charger: PowerWise 48QE high frequency, fully line compensating. 10ft (3m) DC Cord. Underwriters Lab. (U.L.) Listed, (C.S.A. Certified)
Input: 120 Volts AC, 50/60Hz, 8 amps Output: 48 Volts DC at 13 amps
Motor: 48 Volt DC shunt wound, brazed armature, solid copper windings
Drive Train: Direct motor shaft connected to transaxle pinion shaft
Electrical System: 48 Volt DC, six, 8 volt deep cycle batteries (117 minute minimum, 170 amp-hour @ 20 hr. discharge rate)
Transaxle:
Differential with helical gears
Brakes: Dual rear wheel mechanical self-adjusting drum brakes. Automatic single point park brake release with self-compensating system
Capacity: Seating for 4 persons. Rear Seat converts to Cargo Bed
Dimensions Performance
Overall Length 105.3 in (267.0 cm) Seating Capacity 4 Person
Overall Width 48.5 in (123.0 cm) Dry Weight 685 lb (311kg) (Without Batteries)
Overall Height (No Canopy) 52.4 in (133.0 cm) (Top of steering wheel)
Curb Weight 1040 lb (472kg) Trojan T-875
Overall Height (With Canopy) 74.5 in (189.0 cm) (Top of Sun Canopy)
800 lb (363 kg)
Wheel Base 65.5 in (166.0 cm)
Vehicle load capacity
19 ft (5.8 m)
Front Wheel Track 38.0 in (97.0 cm)
Outside Clearance Circle
N/A
Rear Wheel Track 38.5 in (98.0 cm)
Intsecting Aisle Clearance
15.9 mph ± 0.5 mph (25.6 kph ± 0.8 kph)
Gnd Clearance @ Differential 5.5in (14.0 cm)
Speed (Level Ground)
N/A
Load Bed Width 40.0 in (102.0 cm)
Steering & Suspension
Load Bed Length 32.0 in (81.0 cm)
Steering Self-compensating rack and pinion
Vehicle Power
Front Suspension Leaf springs with hydraulic shock absorbers
Power Source 48 Volts DC
Rear Suspension Leaf springs with hydraulic shock absorbers
Motor Type Shunt Wound
Service Brake Rear wheel mechanical self-adjusting drum
Horsepower (kW) 3.0 HP (2.2kW) Continuous
Parking Brake Self-compensating, single point engagement
Electrical System 48 Volt
Front Tires Terra Trac 22 x 11 - 10 / Polished Spoke Whls
Batteries (Qty, Type) Six, 8 Volt Deep Cycle
Rear Tires Terra Trac 22 x 11 - 10 / Polished Spoke Whls
Key or Pedal Start Pedal Start
Body & Chassis
Battery Charger 48 VDC PowerWise™
QE, 120 VAC, UL/CSA
Frame Welded steel with DuraShield™ powder coat
Speed Controller 250 Amp Solid State Controller
Front Body & Finish Injection molded TPO
Drive Train Motor Shaft Direct Drive
Rear Body & Finish Injection molded TPO
Transaxle Differential with helical gears
Standard Color Electric Blue
Gear Selection Dash Mounted Forward-Neutral-Reverse
Rear Axle Ratio 14.76:1
Some items shown may be optional equipment
PRODUCT SPECIFICATION
CONFIGURATION HIGHLIGHTS
PRODUCT OVERVIEW
Specifications are subject to change without notice
* Field installed accessories may require installation charges
Towing Capacity
Noise & Vibration
Sound pressure; continued A-weighted equal to or less
than 70 db(A)
Highest RMS value of weighted acceleration is less than 2.5 m/s 2
Highest RMS value of weighted acceleration is less than 2.5 m/s 2
The uncertainty of measurement is 0.39 m/s 2
Noise
Vibration, WBV
Vibration, HAV
Measurement methods were applied per the ISO 2631 and ISO 5349
standards under coditions of typical vehicle surfaces.