Koga Performance line - E-lement 2015 E-XLR8 - Manual (Page 21)

English–13
0 276 001 SPI | (16.7.14) Bosch eBike Systems
Charger
Safety Notes
Read all safety warnings
and all instructions.
Failure
to follow the warnings and
instructions may result in elec-
tric shock, fire and/or serious
injury.
Save all safety warnings and instructions for future
reference.
The term “battery pack” used in these operating instructions
refers both to standard battery packs (battery packs with
holder on the bike frame) and to rack-type battery packs
(battery packs with holder in the rear rack/carrier).
Keep the charger away from rain or moisture. The
penetration of water into a battery charger increases
the risk of an electric shock.
 Only charge eBike-approved Bosch lithium-ion battery
packs. The battery-pack voltage must match the bat-
tery-pack charging voltage of the charger.
Otherwise
there is danger of fire and explosion.
 Keep the battery charger clean. Contamination can lead
to danger of an electric shock.
 Before each use, check the battery charger, cable and
plug. If damage is detected, do not use the battery charg-
er. Never open the battery charger yourself. Have re-
pairs performed only by a qualified technician and only
using original spare parts.
Damaged battery chargers, ca-
bles and plugs increase the risk of an electric shock.
 Do not operate the battery charger on easily inflamma-
ble surfaces (e. g., paper, textiles, etc.) or surround-
ings.
The heating of the battery charger during the charg-
ing process can pose a fire hazard.
 Vapours can escape in case of damage and improper
use of the battery pack. Provide for fresh air and seek
medical attention in case of complaints.
The vapours
can irritate the respiratory system.
 Supervise children. This will ensure that children do not
play with the charger.
 Children or persons that owing to their physical, sensory
or mental limitations or to their lack of experience or
knowledge, are not capable of securely operating the
charger, may only use this charger under supervision or
after having been instructed by a responsible person.
Otherwise, there is danger of operating errors and injuries.
 Please read and observe the safety warnings and in-
structions enclosed in the operating instructions of the
battery pack and drive unit/cycle computer as well as
in the operating instructions of your eBike.
 A short version of important safety warnings in English,
French and Spanish with the following content can be
found on the bottom side of the charger (marked with num-
ber C4 in the representation on the graphics page):
– For safe operation see manual. Risk of electric shock.
– Dry location use only.
– Charge only batteries of the Bosch eBike Systems.
Other batteries may burst causing personal damage.
– Do not replace the plug assembly as risk of fire or elec-
tric shock may result.
Product Description and
Specifications
Product Features (see page 6 – 8)
The numbering of the product features refers to the illustra-
tion of the battery charger on the graphics page.
C1 Battery charger
C2 Charger socket
C3 Plug-in connector
C4 Safety warnings, charger
C5 Charge connector
C6 Socket for charge connector
C7 Charge socket cover
A2 Rack-type battery pack
A3 Battery charge-control indicator
A4 Battery on/off button
A8 Standard battery pack
Technical Data
Battery Charger Charger
Article number 0 275 007 907
Rated voltage V~ 207 –264
Frequency Hz 47 –63
Output voltage V 36
Charging current A 4
Charging time
– PowerPack 300
– PowerPack 400
h
h
2.5
3.5
Number of battery cells 30 –40
Operating temperature °C –5...+40
Storage temperature °C –10...+50
Weight according to
EPTA-Procedure 01/2003 kg 0.8
Degree of protection IP 40
The values given are valid for a nominal voltage [U] of 230 V. For differ-
ent voltages and models for specific countries, these values can vary.
OBJ_BUCH-2087-002.book Page 13 Wednesday, July 16, 2014 5:12 PM