Sealey TBB300 - Manual (Page 4)

5. operation
 WARNING! Read the safety instructions at the start of this
document before using this product.
5.1 Use as a trailer. If the cart is still in the manual configuration,
refer to 4.4.2 and 4.4.3 for information on converting it to the
towable configuration. See figs.12 & 13 & 14.
5.1.1 NOTE: The maximum towing speed for this product is 10mph.
5.1.2 Do not exceed the 300kg weight capacity of the cart. (One
cubic foot of dirt weighs approximately 68kg).
5.1.3 It is your responsibility to ensure that the towing vehicle is
adequate to tow the trailer and its load. Check that the brakes
are powerful enough. Check that the gross weight of the trailer
does not exceed the towing capacity of the vehicle. The
vehicle's recommended towing limit should be in the vehicle
manufacturer’s handbook.
5.1.4 Use extreme caution when operating the vehicle and trailer on
sloping land especially when the cart is filled to capacity. If in
doubt about stability in any situation, do not proceed.
5.1.5 for best handling and traction always ensure that the load is
evenly distributed in the cart.
5.1.6 To dump material from the cart firstly ensure that the cart is in
the right position and that no one is in the dumping area. To tip
the load, press the foot pedal. Gravity will ensure that a full load
is swiftly shed and therefore no parts of your body should be in
the way of the moving hopper.
5.1.7 Once the load is shed, take hold of the upper edge of the
hopper and pull it back down onto the cart chassis until it
latches back into the notch in the foot pedal lever.
 WARNING! Read the safety instructions at the start of this
document before using this product.
5.2 Use as a hand cart. If the cart is still in the towing
configuration, reverse the process described in section 4.4.2
so that the towing hitch is folded back underneath the tray as
shown in figs.11 and 12. Ensure that the clevis pin and 'R' pin
are correctly installed as shown in fig.5 so that the assembly is
safely locked.
5.2.1 Do not exceed the 300kg weight capacity of the cart. (One
cubic foot of dirt weighs approximately 68kg).
5.2.2 Do not overfill the hopper or load it enevenly as this will make
the cart difficult to manoeuvre. Remember that the cart is now
operating on 3 wheels.
5.2.3 Use extreme caution when moving the cart on sloping land,
especially when the cart is filled to capacity. If in doubt about
stability in any situation, do not proceed.
5.2.4 To dump material from the cart firstly ensure that the cart is in
the right position and that no one is in the dumping area. To tip
the load, press the foot pedal. Gravity will ensure that a full load
is swiftly shed and therefore no parts of your body should be in
the way of the moving hopper.
5.2.5 Once the load is shed, take hold of the upper edge of the
hopper and pull it back down onto the cart chassis until it
latches back into the notch in the foot pedal lever.
fig.15
NOTE: It is our policy to continually improve products and as such we reserve the right to alter data, specifications and component parts without prior notice.
IMPORTANT: No liability is accepted for incorrect use of this product.
WARRANTY: Guarantee is 12 months from purchase date, proof of which will be required for any claim.
INFORMATION: for a copy of our latest catalogue and promotions call us on 01284 757525 and leave your full name and address, including postcode.
01284 757500
01284 703534 [email protected]
Sole UK Distributor, Sealey Group,
Kempson Way, Suffolk Business Park ,
Bury St. Edmunds, Suffolk,
IP32 7AR
www.sealey.co.uk
Web
email
TBB300 Issue No.1 04/11/11 Original Language Version