Graco Inc. 235457 - Manual (Page 2)

2 308-235
Table of Contents
Warnings 2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation/Operation 4 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Pressure Relief Procedure 5 . . . . . . . . . . . . . . . . . . .
System Requirements 5 . . . . . . . . . . . . . . . . . . . . . . .
How to Use the Gun Trigger Safety 5 . . . . . . . . . . .
How to Use the Gun 6 . . . . . . . . . . . . . . . . . . . . . . . .
How to Adjust the Spray Pattern 6 . . . . . . . . . . . . . .
How to Clean the Spray Tip
and Clear a Spray Tip Obstruction 7 . . . . . . . . . . . .
How to Check the Gun Diffuser 8 . . . . . . . . . . . . . . . .
How to Clean the Filter 6 . . . . . . . . . . . . . . . . . . . . . . . .
How to Flush the Gun 8 . . . . . . . . . . . . . . . . . . . . . . . . .
Service 9 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Parts Drawing 11 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Technical Data 14 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Graco Phone Numbers 14 . . . . . . . . . . . . . . . . . . . . . . . . .
Warranty 16 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Symbols
Warning Symbol
WARNING
This symbol alerts you to the possibility of serious
injury or death if you do not follow the instructions.
Caution Symbol
CAUTION
This symbol alerts you to the possibility of damage to
or destruction of equipment if you do not follow the
instructions.
WARNING
INSTRUCTIONS
EQUIPMENT MISUSE HAZARD
Equipment misuse can cause the equipment to rupture or malfunction and result in serious injury.
D This equipment is for professional use only.
D Read all instruction manuals, tags, and labels before operating the equipment.
D Use the equipment only for its intended purpose. If you are not sure, call your Graco distributor.
D Do not alter or modify this equipment.
D Check equipment daily. Repair or replace worn or damaged parts immediately.
D Do not exceed the maximum working pressure of the lowest rated system component. Refer to the
Technical Data on page 14 for the maximum working pressure of this equipment.
D Use fluids and solvents which are compatible with the equipment wetted parts. Refer to the Tech-
nical Data section of all equipment manuals. Read the fluid and solvent manufacturer’s warnings.
D Do not use 1,1,1–trichloroethane, methylene chloride, other halogenated hydrocarbon solvents or
fluids containing such solvents in pressurized aluminum equipment. Such use could result in a
chemical reaction, with the possibility of explosion.
D Do not use hoses to pull equipment.
D Route hoses away from traffic areas, sharp edges, moving parts, and hot surfaces. Do not expose
Graco hoses to temperatures above 66_C (150_F) or below –40_C (–40_F).
D Wear hearing protection when operating this equipment.
D Do not lift pressurized equipment.
D Comply with all applicable local, state, and national fire, electrical, and safety regulations.