John Deere 310SJ - Manual (Page 38)

Net engine power is with standard equipment including air
cleaner, exhaust system, alternator, and cooling fan at test
conditions specified per ISO9249. No derating is required up
to 5,000-ft. (1500 m) altitude for the 310J and up to 10,000-ft.
(3050 m) for the 310J with optional altitude-compensating turbo-
charger, the 310SJ, the 410J, and the 710J. Specifications and design subject to change without notice. Wherever applicable, specifications are in accordance with SAE standards.
Except where otherwise noted, these specifications are based on a 310J unit with 19.5L-24-in. 10PR (R4) tubeless rear and 11L-16-in.
12PR (F3) front tires, 1.00-cu.-yd. (0.76 m
3 ) loader bucket, and 24-in. x 6.5-cu.-ft. (610 mm x 0.18 m 3 ) backhoe bucket; a 310SJ unit
with 19.5L-24-in. 10PR (R4) tubeless rear and 11L-16-in. 12PR (F3) front tires, 1.12-cu.-yd. (0.86 m 3 ) loader bucket, and 24-in. x 7.5-
cu.-ft. (610 mm x 0.21 m 3 ) backhoe bucket; a 410J unit with 19.5L-24-in. 10PR (R4) tubeless rear and 11L-16-in. 12PR (F3) front tires,
1.30-cu.-yd. (1.00 m 3 ) loader bucket, and 24-in. x 7.5-cu.-ft. (610 mm x 0.21 m 3 ) backhoe bucket; and a 710J unit with 21L-28 R-4
(14) rear and 14.5/75-16.1 SL F-3 (10) front tires, 1.62-cu.-yd. (1.24 m 3 ) loader bucket, and 24-in. x 11.1-cu.-ft. (610 mm x 0.31 m 3 )
backhoe bucket.
310J 310SJ 410J 710J Engine
● ● ● ●
Certified to EPA Tier 3 emissions
●
John Deere Model 4045HT054 – 4.5 liter,
84 net peak hp (63 kW) turbocharged, iso-
lation mounted
●
John Deere Model 4045HT054 – 4.5 liter,
93 net peak hp (69 kW) turbocharged, iso-
lation mounted
●
John Deere Model 4045HT054 – 4.5 liter,
98 net peak hp (73 kW) turbocharged, iso-
lation mounted
●
John Deere Model 6068HT067 – 6.8 liter,
126 net peak hp (94 kW) turbocharged, iso-
lation mounted
● ● ● ●
Vertical spin-on engine oil filter
● ● ● ●
Vertical spin-on fuel filter with water separator
● ● ● ●
Oil-to-water engine oil cooler
● ● ● ●
Antifreeze, –34°F (–37°C)
● ● ● ●
Coolant recovery tank
● ● ● ●
Serpentine belt with automatic belt tensioner
● ● ● ●
Suction-type cooling fan
● ● ● ●
Enclosed safety fan guard
▲ ▲ ▲ ▲
High ambient temperature engine cooling
● ● ● ●
Dual-element dry-type air cleaner
● ● ● ●
Muffler, under hood with curved-end
exhaust stack
▲ ▲ ▲
Chrome exhaust extension
▲ ▲ ▲ ▲
Electric ether starting aid
▲ ▲ ▲ ▲
Engine coolant heater, 1,000 watts
Powertrain
● ● ● ●
PowerShift TM transmission: Torque converter
with electrically actuated twist grip F-N-R
with neutral safety switch interlock (1st through
4th gears)
● ● ● ●
Transmission oil cooler
● ● ● ●
Vertical spin-on transmission filter
▲ ▲ ▲
Transmission remote oil-sampling port
● ● ● ●
Differential lock, electric foot-actuated
● ● ● ●
Planetary final drives
● ● ● ●
Power-assisted hydraulic service brakes (con-
form to ISO 3450): Inboard, wet multi-disc,
self-adjusting and self-equalizing
● ● ● ●
Parking/emergency brake with electric switch
control (conforms to ISO 3450): Spring applied,
hydraulically released wet multi-disc / Inde-
pendent of service brakes
● ● ● ●
Hydrostatic power steering with emergency
manual mode
▲ ▲ ▲ ▲
Non-powered front axle
●
Mechanical-front-wheel drive with open
differential: Electric on/off control / Driveshaft
guard / Sealed axle
● ● ●
Mechanical-front-wheel drive with traction
control limited-slip differential: Electric on/off
control / Sealed axle
▲ ▲ ▲ ▲
Rear wheel spacers for use with chains
▲ ▲ ▲
Full MFWD guard
Backhoe
●
Standard dipperstick, 14-ft. 3-in. digging depth
●
Standard dipperstick, 14-ft. 6-in. digging depth
●
Standard dipperstick, 15-ft. 10-in. digging depth
●
Standard dipperstick, 17-ft. 10-in. digging depth
▲ ▲
Extendable dipperstick, 3-ft. 6-in. extension
▲
Extendable dipperstick, 4-ft. extension
▲
Extendable dipperstick, 4-ft. 6-in. extension
▲
Heavy-duty backhoe bucket cylinder option
● ● ● ▲
Two-lever (Deere) backhoe controls
▲ ▲ ▲ ●
Two-lever pilot controls with pattern-selection
feature
● ● ● ●
Backhoe transport lock lever
● ● ● ●
Swing lock pin stored in operator’s station
● ● ● ●
Stabilizers with two-direction anti-drift valves
● ● ● ●
Pivoting stabilizers with reversible pads
310J 310SJ 410J 710J Backhoe (continued)
▲
Extended (long) stabilizers with reversible pads
● ● ● ●
Less bucket, with bucket pins
▲ ▲ ▲
Standard-duty backhoe bucket with lift loops
▲ ▲ ▲ ▲
Heavy-duty backhoe bucket with lift loops
▲ ▲ ▲
Severe-duty backhoe bucket with lift loops
▲ ▲ ▲
Backhoe coupler for “C,” “D,” “E,” and “G”
Series John Deere, Case, and Cat buckets
▲ ▲ ▲ ▲
Auxiliary backhoe valve for swingers, thumbs,
etc. with auxiliary plumbing
▲ ▲ ▲ ▲
Auxiliary backhoe valve for hammers and
compactors with auxiliary plumbing
▲ ▲ ▲
Hydraulic thumb
Loader †
● ● ● ●
Loader bucket anti-spill (rollback)
● ● ● ●
Return-to-dig feature
● ● ● ●
Single-lever control with electric clutch cutoff
switch
● ● ● ●
Bucket-level indicator
● ● ● ●
Loader boom service lock
▲ ▲ ▲ ▲
Ride control
▲ ▲ ▲ ▲
Auxiliary loader hydraulics with two-lever control
▲ ▲ ▲ ▲
Hydraulic coupler for buckets, forks, etc.
● ● ● ●
Less bucket, with bucket pins
● ● ●
High-visibility loader arms
Hydraulic System
●
28-gpm (106 L/min.) gear pump, open center
system
●
36-gpm (136 L/min.) tandem gear pump, open-
center system
●
42-gpm (159 L/min.) axial piston pump, PCLS
system
●
52-gpm (197 L/min.) axial piston pump, PCLS
system
● ● ● ●
Independent hydraulic reservoir
● ● ● ●
“O”-ring face seal connectors
● ● ● ●
6-micron vertical spin-on filter
Electrical System
● ● ● ●
12-volt system
● ● ● ●
90-amp alternator
● ● ●
Single battery with 190-min. reserve capacity
and 950 CCA
▲ ▲ ▲ ●
Dual batteries with 380-min. reserve capacity
and 1,900 CCA
● ● ● ●
Positive terminal battery cover
● ● ● ●
Blade-type multi-fused circuits
● ● ● ●
By-pass start safety cover on starter
▲ ▲ ▲ ▲
Master disconnect switch
● ● ● ●
Jump/auxiliary start terminal
Lights
●
Halogen lights (4), 32,500 candlepower each
(2 front driving/working and 2 rear working)
▲ ● ● ●
Additional halogen work lights (6), 32,500
candlepower each (2 front, 2 rear, and 2 side
docking)
● ● ● ●
Turn signal/flashing (2 front and 2 rear)
● ● ● ●
Rear stop and tail (2)
● ● ● ●
Rear reflectors (2)
Operator’s Station
● ● ● ●
Modular-design ROPS/FOPS canopy with
molded roof (conforms to SAE J1040): Iso-
lation mounted
● ● ● ●
Left and right access
● ● ● ●
Slip-resistant steps and ergonomically located
handholds (conform to SAE J185)
● ● ● ●
Molded floor mats
● ● ● ●
Headliner
● ● ● ●
Coat hook
● ● ● ●
12-volt outlets (2 cab, 1 canopy)
● ● ● ●
Built-in beverage and Thermos bottle holders
● ● ● ●
Built-in Operator’s Manual storage compart-
ment with manual
310J 310SJ 410J 710J Operator’s Station (continued)
● ● ● ●
Interior rearview mirror
▲ ▲ ▲ ▲
Outside rearview mirrors
● ● ● ●
Rotary hand throttle
● ● ● ●
Suspended foot throttle
▲ ● ● ●
Tilt steering
● ● ● ●
Horn
● ● ● ●
Key start switch with electric fuel shutoff
▲ ▲ ▲ ▲
Electronic anti-theft enabled through monitor
● ● ● ●
Engine coolant temperature gauge, illuminated
electronic, with audible warning
● ● ● ●
Oil temperature gauge, illuminated electronic,
with audible warning
● ● ● ●
Fuel gauge, illuminated electronic
● ● ● ●
Digital display of engine hours, engine rpm,
and system voltage
● ● ● ●
Monitor system with audible and visual warn-
ings: Engine air restriction indicator / Low
alternator voltage indicator / Engine oil pres-
sure indicator with audible warning / Hydraulic
filter restriction indicator / Parking brake on/
off indicator with audible warning / Seat belt
indicator / Low brake pressure / Machine
diagnostic information via 4-push-button/LCD
operator interface
● ● ● ●
Mechanical suspension deluxe vinyl swivel
seat with lumbar adjustment and armrests
(fully adjustable)
▲ ▲ ▲ ▲
Mechanical suspension deluxe fabric swivel
seat with lumbar adjustment and armrests
(fully adjustable)
▲ ▲ ▲ ▲
Air suspension deluxe fabric swivel seat
with lumbar adjustment
● ● ● ●
Seat belt, 2-in., with retractor
▲ ▲ ▲ ▲
Seat belt, 3-in., with retractor
▲ ▲ ▲ ▲
Cab: Headliner, dome light, left and right cab
doors, tinted safety glass, windshield wiper
(one rear and one front), front windshield
washer, fresh-air intake, heater/defroster/
pressurizer (40,000-Btu/hr. [11.7 kW] heater),
and 12-volt outlets (2)
▲ ▲ ▲ ▲
Air conditioner (26,000-Btu/hr. [7.6 kW]
output and CFC-free R134a refrigerant)
▲ ▲ ▲ ▲
AM/FM/weather-band radio
▲ ▲ ▲ ▲
AM/FM/weather-band radio with CD player
Overall Vehicle
● ● ● ●
One-piece unitized construction mainframe
● ● ● ●
Vehicle tie-downs (2 front and 2 rear)
● ● ● ●
Remote grease bank for front axle
● ● ●
Heavy-duty front bumper
▲ ▲ ▲
450-lb. (204 kg) front counterweight
▲ ▲ ▲
700-lb. (317 kg) front counterweight
▲ ▲ ▲
1,000-lb. (454 kg) front counterweight
▲ ▲ ▲
1,250-lb. (567 kg) front counterweight
▲ ▲ ▲
1,450-lb. (657 kg) front counterweight
●
930-lb. (422 kg) front counterweight
▲
1,630-lb. (740 kg) front counterweight
▲ ▲ ▲
Rubber grille bumpers
● ● ●
Fuel tank, 41 gal. (155 L), ground-level fueling
●
Fuel tank, 69 gal. (261 L), ground-level fueling
● ● ● ●
Two-position easy-tilt hood
● ● ●
Extended grille frame
● ● ● ●
Removable toolbox with padlock hasp
● ● ● ●
Vandal protection for locking monitor,
engine hood, toolbox, hydraulic reservoir,
and fuel tank
● ● ● ●
Reverse warning alarm
▲ ▲ ▲
Sound-reduction package
● ● ● ●
Dent-resistant full-coverage rear fenders
▲ ▲ ▲ ▲
JDLink TM wireless communication system
† See dealer for range of heavy-duty, multipurpose, and coupler
buckets and forks.
310J / 310SJ / 410J / 710J BACKHOE LOADERS
Key: ●
Standard equipment
▲
Optional equipment *See your John Deere dealer for further information.
Vertis QCA
1300 19th Street, Suite 200
East Moline, IL 61244
Cyan Magenta Yellow Black DKAJLBH Page 38