John Deere Tractor 100 Series OMG X23532 J0 - Manual (Page 33)

Service Transmission - 32
SERVICE TRANSMISSION
MX13768b
6. Slide hose clamps (A) away from fuel filter (B) using a pliers.
7. Disconnect hoses from filter, and raise fuel lines vertically to avoid fuel
drainage.
8. Connect hoses to new filter making sure the filter arrow is pointed in the
direction of the fuel flow.
9. Install clamps and check for leaks.
10. Lower hood.
Service Transmission
Checking Transmission
The transmission is a sealed component. No maintenance is required on
this transmission. If you suspect any transmission problems, please
contact your authorized dealer.
Service Mower
Removing or Installing Mower Drive Belt at Engine
Drive Sheave (122 cm (48 in.) and 137 cm (54 in.)
Mower Deck)
1. Park machine safely. (See Parking Safely in SAFETY section.)
2. Put lift lever in lowest position.
MX25905
3. Put a 15 mm closed wrench or a socket on the idler sheave nut (A) and
rotate clockwise to move idler sheave toward front of tractor and hold to
release belt tension.
4. Remove belt (B) from drive sheave (C), and release tension on sheave
nut (A).
5. To install the belt on the drive sheave, rotate idler sheave nut clockwise
to move idler sheave toward front of tractor, and install belt on drive
sheave.
6. Release idler sheave nut to tighten belt.
Removing Mower Deck
1. Park machine safely. (See Parking Safely in SAFETY section.)
2. Put wood blocks under each side of mower deck.
3. Put attachment lift lever in lowest position, bringing mower deck down
onto blocks.
MX7681a
Picture Note: 107 cm (42 in.) mower deck only.
4. On machines with 107 cm (42 in.), disconnect mower engagement drive
cable (A) on left side of mower deck.
IMPORTANT: Avoid damage! Incorrect installation of fuel filter
may cause engine damage. Install the filter with the arrow
pointing in the direction of fuel flow (towards the engine) for
proper operation.
A
B
c
CAUTION: Avoid injury! Component is spring-assisted and
under tension. Injury can occur if spring-assisted component is
released suddenly.
B
A
C
E
B
A
C
D