North Star 5500 - Manual (Page 5)

4
GENERATOR FEATURES
Reference 1 - Circuit Breakers. This portable
single phase generator has 2, 20 amp (A) push to
reset circuit breakers to protect against electrical
overloads.
Reference 2 - 120/240V Receptacle. The locking
device is a 120/240V 20A NEMA L14-20R receptacle.
This receptacle accepts a NEMA plug number L14-
20P.
ALWAYS use grounded male plugs. The neutral
line of the generator is mechanically grounded to the
frame. Matching NEMA male plugs must always be
used.
Reference 3 - Grounding Post. Ground the
generator via the grounding post, to a copper pipe or
rod that is driven into moist soil.
Reference 4 - 120V Receptacle. The generator
has a control panel with one duplex (two receptacles in
a common housing) receptacle and one locking device
receptacle. The duplex is a 120 volt (V) 20 amp (A)
straight blade receptacle, National Electrical
Manufacturer’s Association (NEMA) number 5-20R.
This receptacle accepts NEMA plug numbers 5-15P
and 5-20P. Each receptacle on the duplex is capable
of drawing 20A.
Reference 5 - Oil Drain Plug. Refer to your
Honda engine manual for oil change
recommendations.
Reference 6 - Engine Stop Sw itch. The red
engine stop switch is located on the engine. Always
locate this switch and be familiar with its location
before operating the generator.
Reference 7 - Decal.
Reference 8 - Air Cleaner. Refer to your Honda
engine manual for air cleaner care.
Reference 9 - Super Silent Muffler. 8 dB less
than Honda’s standard muffler.
Reference 10 - Gas Cap w ith Gauge. The gas
cap is extra large, creating a large hole for refilling and
a comfortable grip. You can always monitor the
fuel level without removing the cap by using the
fuel level indicator built into the gas cap.
Reference 11 - 6.5 Gallon Gas Tank. Large tank
allows for extended run capabilities. Always allow
room for gasoline expansion by not filling the gas tank
completely full.
Reference 12 - Generator Head. The electricity
producing part of the generator.
Reference 13 - Vibration Isolation Mounts. The
engine and generator head, are mounted on rubber
cylinders that absorb most of the engine vibration.
Reference 14 - Recoil. Grasp firmly when
starting engine.
Reference 15 - Choke Lever. Used during cold
starts. Refer to the Honda engine manual for usage.
Reference 16 – Fuel Valve Lever. The Honda
engine has an ON-OFF valve. Always keep this valve
closed when the generator is not in use. Always keep
this valve closed while transporting the generator.
Low Oil Shutdow n. The Honda engine is
protected against damage resulting from low oil level.
As the oil falls below the safe level, the engine
automatically shuts off (the engine stop switch remains
in the on position). The engine will not start until the
oil is refilled to above the safe level.
INTRODUCTION
Before starting your generator, thoroughly study
the instructions and cautions in this manual to assure
you are fully acquainted with the operation of all
components of this generator. Proper preparation,
operation and maintenance will result in operator
safety, best performance and long life of the generator.
For detailed engine operation and maintenance always
refer to the Honda engine owner’s manual furnished
with the generator (Honda refers to the 8 Hp engine as
a GX240).
NorthStar is constantly improving its products.
The specifications outlined herein are subject to
change without prior notice or obligation. The
purchaser and/or user assumes liability of any
modification and/or alterations on this equipment from
original design and manufacture.
Before using, the user shall determine the
suitability of this product for its intended use and
assumes liability therein.
ANSI SAFETY DEFINITIONS
DANGER indicates an imminently hazardous
situation which, if not avoided, will result in death or
serious injury. This signal word is to be limited to the
most extreme situations.
WARNING indicates a potentially hazardous
situation which, if not avoided, could result in a
death or serious injury.
CAUTION indicates a potentially hazardous
situation, which if not avoided, may result in minor or
moderate injury. It may also be used to alert against
unsafe practices.
RULES FOR SAFE OPERATIONS
Safety precautions are essential when operating
this generator.
Respectful and cautious operation will
considerably lessen the possibilities of a personal
injury. This manual will warn of specific personal injury
potential, and these will be designated by the symbol: