S&B Filters Cold Air Intake Kit - Cotton Filter 75-5054 User Manual
Installation instructions, Vehicle application
1.
With the ignition switched off and the
parking brake set, disconnect the negative
battery cables on both batteries using a 8mm
wrench or socket.
Installation Instructions
Vehicle Application
Year: 2008-10
Make: FORD
Model:
F-250, F-350, F-450, F-550
Engine:
6.4L Power
Stroke
Tools Required
• 8mm &10mm Wrench & Socket
• T-20 Security Torx Wrench (Supplied w/ Kit)
• 5/16” Nut Driver or Flat Blade Screwdriver
• Phillips Screwdriver, Pliers or Channel locks
Notes
Kit may not fit with the following
Aftermarket Parts installed:
• Body Lift or Lowering Kit
• Custom Hood
• Intercooler or Turbo upgrades
15461 Slover Ave., Fontana, CA 92337 - Phone: (909) 947-0015 - Fax: (909) 947-0603 -
4.
Disconnect the electrical connection from
the MAF sensor at the OE air box.
7.
Loosen the OE hose clamp at the turbo
inlet.
2.
Unclip the OE air box lid and pull the hot
air supply tube out and remove the lid.
5.
Disconnect the electrical connection from
the OE restriction gauge. Note: Do not rely on
OE restriction gauge or until the dash light is
triggered before you service your S&B filter.
8.
Loosen the OE hose clamp at the air box
connection.
3.
Remove the OE air filter from the air box.
6.
Use a flathead screwdriver to pry the
wire loom retaining clip from the OE air box.
9.
OE air box Removal: Grasp the air box at
the end and lift up, separating the prongs
from the grommets at the bottom of the box.
P/N: 75-5054 / 75-5054D
SEE EXPLODED VIEW ON PAGE 4
1
S&B Filter Maintnance
Cleanable
(KF-1052)
. If the enclosed filter is Red, it came pre-oiled
from the factory. Please visit
for exact oil
amount required after cleaning.
Disposable
(KF-1052D)
. If the enclosed filter is White, it is a
disposable filter and should be discarded once it reaches capacity.
This filter
(does not require oil)
. For more info on S&Bʼs disposable
filter, visit
.
Before You Start
• Please read the entire product guide before proceeding.
• Ensure all components listed on page 4 are present.
• If you are missing any of the components, call our customer
support at (909) 947-0015.
• Do not work on your vehicle while engine is hot.
• Make sure the engine is turned off and the vehicle is in Park or
the Parking Brake is set.
CARB Status - Pending
Product has been submitted to Air
Resources Board for approval.
Not Legal for use in CA or other states
adopting CA emissions standards
See Page 3 for more info.