King Technology POOL FROG Model 5400/5430 - Manual (Page 17)

17
POOL FROG
CYCLER
POOL FROG
CYCLER
For Proper Performance
1) If using a multi-speed pump, run pump for at
least 6 hours per day at high speed (at least
40 gpm).
If the pump will run on low speed 24 hours per
day or less than 6 hours per
day on high speed, you must
bleed the air while the pump is
on by unscrewing the cap knob
until water appears. Then screw
the knob back on. Repeat this
process each time the cap is
removed for any reason.
2) Install system with 4-8 psi back pressure.
Lower back pressures could result
in under chlorination. Adjust eye
ball fittings in the return jets to
a smaller size to increase back
pressure. Contact King Technology
at 800-222-0169 for a cap tapped
for a pressure gauge to determine
back pressure at pool start-up.
3) Special installation:
• If water flow is higher than 80 gpm, see
diagram A.
• If an in-floor cleaner is included with pool,
see diagram B, with two options. Preferred
installation is Option 1 with two separate lines.
• If set-up is a pool and spa combination with
common equipment, see diagram C.
• Any additional sanitizing equipment that is
installed with FROG® must be installed after
FROG® (never before) on the return line
to the pool.
NOTE: Over chlorination or damage to the POOL
FROG® Cycler or other equipment could result if
these special installations are not used in these
situations.
A. With High GPMS
Install T-fittings exactly as shown.
C. Pool and Spillover Spa Combination
B. With In-Floor Cleaner - TWo oPTIoNS
✙
B. With In-floor Cleaners
✙
✙
✙
✙
POOL FROG
CYCLER
In-floor
cleaner valve
POOL WATER LEVEL
POOL WATER LEVEL
Flow
Flow
The best option is to have two lines. One line with pump, filter, heater
and cycler and a second line with a separate pump for the in-floor clean-
ing system (filter optional).
oPTIoN 1- A Two-line Installation
oPTIoN 2 - A 3-Way Valve Installation
POOL WATER LEVEL
POOL WATER LEVEL
POOL WATER LEVEL
POOL RETURN
3-way manual valve or 3-way motor valve plus controls
POOL FROG®
CYCLER
POOL FROG®
CYCLER
IN-FLOOR
CLEANER VALVE
IN-FLOOR
CLEANER VALVE
FILTER
PUMP
PUMP FLOW
FLOW PUMP
HEATER
FILTER
FILTER
line 1
line 2