Grant Part #52203 - Revolution - Manual (Page 4)

8. Position the airbag module into the wheel and reinstall the 2 airbag module retaining bolts removed
earlier; tighten to 7 N-m (62 lb-in). Reinstall the plastic bolt plugs into the wheel.
REPOWERING AND CHECKING THE AIRBAG SYSTEM
Make sure no one is in the vehicle and there is nothing blocking or placed in front of the
airbag module when the power is being reconnected. Failure to follow these instructions may
result in serious personal injury in the event of an accidental deployment.
1. Turn the ignition switch from OFF to ON. Reinstall the restraint control module (RCM) fuse into the
correct slot in the Smart Junction Box (SJB) and close the cover. Reconnect any auxiliary batteries
or power supplies (if so equipped). Reconnect the negative battery cable.
2. Turn the ignition key from ON to OFF. Wait 10 seconds, then turn the key back to ON and visually
monitor the airbag warning indicator. It may take approximately 30 seconds after the ignition switch
has been turned from the OFF to the On position for the light to come on as this is the time required
for the RCM to complete the testing of the circuit. The light should come on for 6 seconds then turn
off. If a fault is present in the system the light will either fail to come on at all or remain lit
continuously. If either of these occurs refer back to “Disabling and Removal Of The Airbag Module”
to check your connections. If the light should flash and you hear an audible beep this means the
RCM is not configured and you should take your vehicle to a Ford dealer immediately.
3. Remember to reset your radio station presets and clock and enjoy your new GRANT REVOLUTION
steering wheel. When you first start the vehicle the engine may run less smoothly than before as the
computer will have to reset itself due to the power loss but this will just take a moment or two.
If you need further assistance contact GRANT Technical Service Support at:
Phone (626) 305-0700 Fax (626) 305-0799
Email: [email protected]
Support Hours are 8:00AM to 5:00PM Pacific Time
Monday through Friday
OUR LIMITED WARRANTY
We warrant this product for ninety (90) days from the date of original purchase to be free from defects in materials and workmanship. If, during
this period, the product fails under normal usage because of a manufacturing defect, then we will replace or repair the item. To obtain repair or
replacement under the terms of this warranty, notify us at 615 Elca Lane, Suite C, Brownsville, TX 75821. Proof of purchase and date of
purchase are required to validate warranty.
All implied warranties, including warranty of merchantability, are limited to this same ninety-day period from date of original
purchase. We are not liable for any direct or consequential loss of property damage arising from any use of this product. This
warranty gives you specific legal rights, and you may also have other rights which vary from state to state. Offer good in U.S.A. and
Canada only.
GRANT PRODUCTS INTERNATIONAL, INC.
615 Elca Lane, Suite C
Brownsville, TX 75821
On the Web: www.grantproducts. com Rev. 5/10 by JF Form 97581-00-01