Foredom T35A - Manual (Page 2)

Lubricating the T-35A Handpiece
Oil daily prior to use with 2 drops of Foredom
Handpiece Lubricant in dispenser.
1. Turn Oil Hole Ring so that oil hole aligns with
red dot on handpiece housing.
2.Squeeze 2 small drops of oil into hole using
oil dispenser.
3. Turn oil ring about 1/4 turn to cover hole.
4. Run handpiece briefly to spread oil while cover-
ing rear exhaust ports with a cloth or paper
towel to catch any excess oil that may blow out.
Caution: Never clean the turbine’s head
with compressed air– it can damage
the bearings.
Maintenance of Air Filter
If you ever notice an accumulation of liquid in
the air filter container, press the evacuation
valve upwards to evacuate the liquid. Check
your air source’s filter.
Oil Hole Ring
Oil Dispenser
Oil
Hole
Collet
Release
Plunger
Red
Dot
Installing/Replacing the
Turbine Cartridge with Collet
To remove a Turbine Cartridge follow these
instructions:
1.Remove the Nose Cap using the small end (8mm)
of the spanner wrench, and turn it counterclockwise.
2.Remove Turbine Cartridge by pulling it out
with fingertips.
To insert a new cartridge or to re-insert
one, be sure to follow these steps:
1.Line up the small knob or button on the
Turbine Cartridge (see below) with the Groove
inside the front part of the Handpiece Housing
(at left below) while inserting the Turbine Cartridge.
This is necessary for the cartridge to seat correctly
with the air ports in proper alignment.
2. When Turbine Cartridge with Collet is inserted into
position, screw on nose cap. Tighten firmly with
small end of spanner wrench. Insert a bur and
run handpiece briefly to be sure that it is
functioning properly.
Turbine Cartridge
with Collet
Small Knob
or button
Nose
Cap
Groove
The Foredom T-350K 2 Air Turbine
Kit Contains:
T-35A Handpiece with hose adapter
and instructions
Air Filter/Regulator in stand/wall mount
Push fittings
3 Assorted Carbide Burs
Owner’s Manual
2– 6’ lengths of Air Hose (The hose connecting
compressor to filter/regulator is not supplied.)
On/Off Foot Pedal
Form 906 n 1/03 Printed in USA
LIMITED WARRANTY
Foredom warrants the T-35A Air Turbine
handpiece to be free of defects in material or
workmanship for a period of 1 year after
purchase. This warranty does not cover
damage caused in transit or by accident,
misuse, or ordinary wear. Repair or replace-
ment will be made at our option if the
product is returned post-paid to the address
on reverse. All warranty repairs must be done
at the factory. This warranty only covers the
original purchaser of the product.
Rev T-35A Inst. 2/7/03 2:38 PM Page 2