Ybravo BRAVO 25 Mower 25-201 - Kawasaki - Manual (Page 9)

9
ASSEMBLY - SETUP
Taking the following precautions will lessen the
risk of injury and property damage.
Use extreme care in handling gasoline. Gasoline is
extremely fl ammable and the vapors are explosive.
- Extinguish all cigarettes, cigars, pipes, and other
sources of ignition.
- Use only approved gasoline containers.
- Never remove gas cap or add fuel with the engine
running.
- Allow engine to cool a minimum of 3 minutes
before refueling.
- Never fuel the machine indoors.
- Never store the machine or fuel container where
there is an open fl ame, spark, or pilot light such
as on a water heater or other appliances.
- Never fi ll containers inside a vehicle or on a truck
or trailer bed with a plastic liner. Always place
containers on the ground away from your vehicle
when fi lling.
- Remove the mower from the truck or trailer and
refuel it on the ground. If this is not possible,
then refuel the equipment with a portable container,
rather than from a gasoline dispenser nozzle.
- Keep the nozzle in contact with the rim of the fuel
tank or container opening at all times until fueling
is complete. Do not use a nozzle lock-open device.
- If fuel is spilled on clothing, change clothing
immediately.
- Never overfi ll fuel tank. Always wipe off any
spilled fuel or oil. Replace fuel cap and tighten.
WARNING
MAXIMUM
FUEL LEVEL
FUEL FILLER
NECK
FUEL FILLER CAP
APPROVED FUEL
CONTAINER
STEP 8 Honda Engine
Verify that the throttle control is adjusted properly as follows:
- Move the throttle control to the Full Throttle position.
- In the full throttle position the two arms at the throttle
mechanism on the engine should touch as illustrated below.
Choke
Full Throttle Idle Throttle
Engine Off
OK
Following these steps for the throttle adjustment will ensure
that the Honda engine performs properly for this mower.
The engine speed was adjusted at the factory to be
approximately 3500 to 3600 RPM.
NOTICE:
The engine speed should preferably be checked and verifi ed
with a tachometer. Normal full throttle speed of the engine
should be adjusted to 3500 to 3600 RPM. An authorized
Honda or Kawasaki Engine Dealer can verify and adjust the
engine speed properly.
Following these steps for the throttle adjustment will ensure
that the Kawasaki engine performs properly for this mower.
The engine speed was adjusted at the factory to be
approximately 3500 to 3600 RPM.
STEP 8 Kawasaki Engine
Verify that the throttle control is adjusted properly as follows:
- Move the throttle control to the Choke position.
- In the Choke position the arm attached to the throttle cable at
the engine should bottom out at the arrow.
Choke
Full Throttle Idle Throttle Engine Off
(BBC version)
STEP 9
Before fi lling the engine with gasoline - follow all instructions
in this manual as well as all instructions provided in the Honda
or Kawasaki engine Owner’s Manual.
Maximum fi ll volume:
Honda: 1.5 Qt (1.4 Liter) - 86 octane or higher
Kawasaki: 1.9 Qt (1.8 Liter) - 86 octane or higher
The engine will not operate on gasoline marketed as
E-85 (85% ethanol)