Badger Meter Recordall Compound Series Meters - Manual (Page 8)

Figure 2: Measuring element assembly, 8"
SERVICING PARTS AND ASSEMBLIES
This section contains information about general maintenance and servicing . Instructions for disassembling the Recordall
Turbo Series mainline meter for servicing can be found in the Recordall Turbo Series Meter User Manual . Also see the Recordall
Combo Meter Parts List for part numbers of replaceable components and correct ordering information . If satisfactory repair
cannot be made, contact Badger Meter .
Instructions for servicing the Disc Series bypass meter can be found in the Recordall Disc Series Meter User Manual . Component
detail can be found in the Recordall Disc Series Meter Parts List.
When the performance of the Combo Meter indicates a need for servicing of the Recordall Turbo Series meter, refer to the
following instructions pertaining to removal, inspection and installation of service parts and assemblies . With the Recordall
Turbo Series unitized construction, service is simplified with a reduction in required product maintenance training . Also see
the Recordall Turbo Series Meter Parts List for part numbers of replaceable components for ordering information . If satisfactory
repair cannot be made, contact Badger Meter .
Maintenance
Badger Meter products have been carefully designed to be as maintenance-free as possible . However, depending upon
installation location and condition of water being metered, maintenance may occasionally be required . The maintenance
and inspection procedure can also be used as a guide to locating a problem in the unit that may be the cause of abnormal
meter operation .
Meters can be serviced without removing them from the line . A typical installation would be equipped with drain and piping
valves . To inspect or replace components of the head assembly for the turbo or the chamber assembly in the disc meter,
close the upstream and downstream valves . However, if the installation does not have a drain valve, proceed as follows to
relieve pressure:
Recordall® Combo Meter, 8"
Page 8 October 2013