Smittybilt 97203 XRC 3.0 3,0001b Winch - Manual (Page 2)

MOVING PARTS ENTANGLEMENTHAZARD
Failure to observe these instructions could lead to severe injury or death.To avoid
injury to hands or fingers:
Always keep han ds clear of ro pe, hook loop, hook and fairlead opening during
installation, operation and when spooling in or out.
Always use extreme caution when handling hook and rope during spooling
operations.
Always use supplied hook strap whenever spooling rope in or out, during in
stallation, and during operation.
Always keep vehicle in sight during winching operation.
Always wear heavy leather gloves when handling rope.
CHEMICAL AND FIRE HAZARD
Failure to observe these instructions could lead to severe injury or death.
Always remove jewelry and wear eye protection.
Never lean over battery while making connections.
Always verify area is clear of fuel lines, fuel tank, brake lines,electrical wires, etc.
When drilling.
Never route electrical cables:
- Across any sharp edges.
- Through or near moving parts.
- Near parts that become hot.
Always insulate and protect all exposed wiring and electrical terminals.
Always install terminal boots as directed in installation instructions.
MOVING PARTS ENTANGLEMENT
HAZARD
Failure to observe these instructions could lead to minor or moderate injury.
Always keep wired remote control lead clear of the drum, rope and rigging.
Inspect for cracks, pinches, frayed wires or loose connections. Replace remote
control if damaged.
Always pass wired remote control through a window to avoid pinching lead in door,
when using remote inside a vehicle.
Never leave remote control where it can be activated during freespooling, ri gging, or
when the winch is not being used.
Always require operator and bystanders to be aware of vehicle and or load.
MOVING PARTS ENTANGLEMENT
HAZARD
Failure to observe these instructions could lead to minor or moderate injury. General
Safety:
Always know your winch. Take time to fully read the Installation Guide and the Basic
Guide to Winching Techniques in order to understand your winch and its operation.
Never operate this winch if you are under 16 years of age.
Never operate this winch when under the influence of drugs, alcohol or medication.
Never exceed winch or rope capacity listed on product data sheet. Double line
using a snatch block to reduce winch load.Installation Safety:
Always choose a mounting location that is sufficiently strong to withstand the
maximum pulling capacity of your winch.
Always use factory approved mounting hardware, components, and
accessories.
Always use grade 5 (grade 8.8 metric) or better mounting hardware.
Never weld mounting bolts.
Always use care when using longer bolts than those supplied from factory. Bolts
that are too long can damage the base and/or prevent the winch from being mounted
securely.
-3- -4-
XRC 3.0 3,0001b Winch
Part # 97203
WWW.SMITTYBILT.COM
XRC 3.0 3,0001b Winch
Part # 97203
WWW.SMITTYBILT.COM