JLG 40H Parts Manual - Manual (Page 175)

3120241 2-111
S
E
C
T
I
O
N
2
T
U
R
N
T
A
B
L
E
SECTION 2 TURNTABLE
FIGURE 2-29. DEUTZ F3L1011 ENGINE INSTALLATION
FIG & ITEM # PART NUMBER DESCRIPTION QTY. REV.
0251290 DEUTZ ENGINE ASSEMBLY F3L-1011 Ref. 12
1 2000107 Engine, Deutz F3L1011 Diesel (Prior to July 1995) 1
2000138 Engine, Deutz F3L1011 Diesel (July 1995 to Present) 1
7000694 Muffler 1
2 3600139
Pump Assembly - Main (See Figure 2- 42 for Break-
down)
1
3 0641812 Bolt 1/2"-13NC x 1 1/2" 2
4 4761800 Lockwasher, 1/2" 2
5 2180730 Fitting 1
6 2420110 Sender, Oil Pressure 1
Note: See end of parts list for items located at item
6 when equipped with generator.
Ref.
7 Not Used
8 1060045 Cable, Battery 1
9 0080172 Adapter, Throttle (Prior to July 1995) 1
4460302 Adapter, Throttle (July 1995 to Present) 1
10 3450202 Pin, Cotter 1
11 3951003 Screw #10-24UNC x 3/8" (Prior to July 1995) 1
0902244 Bracket, Throttle (July 1995 to Present) 1
12 3960407 Gasket, Intake Adapter 1
13 0080177 Adapter Weldment 1
14 3311501 Nut 5/16"-18UNC-2B 5
15 4761500 Lockwasher 5/16" Nominal 5
16 0641512 Bolt 5/16"-18UNC x 1 1/2" 3
17 0901705 Bracket, Muffler 1
18 1320176 Clamp, Muffler 1 7/8" U-Bolt 3
19 0701010 Bolt 10mm x 20mm 4
20 4832000 Lockwasher 10mm Nominal 4
21 Harness 42" Long 1
1060054 Harness Prior to February 1990 1
4920929 Harness February 1990 to June 1992 1
4920960 Harness June 1992 to Present 1
22 Harness
1060221 Harness Prior to February 1990 1
4920946 Harness February 1990 to Present 1
23 4843740 Air Intake 1
24 3960389 Seal, Intake 1
25 0100001 Adhesive, Dual (Not Shown) (Prior to July 1995 Only) A/R
26 3600071 Pump Assembly
7004247 Pump Only 1
7004249 Coupling Only 1
7004248 Motor, Replacement 1
7004436 Motor with Bracket 1
7012576 Bracket Only 1
27 0080174 Adapter 4
28 0641606 Bolt 3/8"-16UNC x 3/4" 2
29 4761600 Lockwasher 3/8" 5
30 0641610 Bolt 3/8"-16UNC x 1 1/4" 3