JLG 510AJ Parts Manual - Manual (Page 89)

3121182 510AJ 2-43
SECTION 2 TURNTABLE
Ref. ENGINE COMPONENTS
2000273 Ref. Belgium Built Machines S/N 1300000981 to S/N 1300001788
(F3M2011 Tier II)
2000338 Ref. Belgium Built Machines S/N 1300001788 to S/N 1300003197
(F3M2011 Tier II)
1001092723 Ref/ Belgium Built Machines S/N 1300003197 to Present
(D2011L03 Tier III)
1001092723 Ref/ Romanian Built Machines S/N E300000100 to S/N E300001114
(D2011L03 Tier III)
401 7020026 1 Dipstick (was p/n 7027244)
402 7020465 2 Cap, Filler
403 7020495 1 Pump, Oil Lube (Not Shown)
7020468 1 Seal Between Oil Pump & Engine Block (Not Shown)
404 7016331 1 Filter, Oil
7027236 1 Sensor, Oil Temperature (Not Shown - Located in Rear Of Filter
Mount)
405 3 Pump, Injector Options:
7027246 Series A Injector
7027608 Series B Injector
7027609 Series C Injector
7027610 Series D Injector
7020447 3 Gasket, Injector Pump
406 7020023 1 Filter, Fuel
70001423 1 Bracket, Fuel Filter
407 Use 70000916 1 Pump Fuel Supply (was p/n 7027238)
7020411 1 O-Seal Between Fuel Pump & Engine Block (Not Shown)
70001435 1 Replacement Filter
408 7020449 3 Gasket, Intake Manifold (Not Shown)
7020471 3 Gasket, Exhaust (Not Shown)
70002200 6 Stud, Exhaust (Not Shown)
410 7027791 1 Sensor, Temperature
411 Use 7000663 1 Alternator (was p/n 7020410)
7020464 Regulator, Voltage (Not Shown)
412 7020479 1 Starter
7026608 1 Relay, Starter
413 7024565 1 Tacho-Generator
70003932 1 Sleeve, Spacer
414 7027792 1 Actuator, Throttle
7027276 2 Spring, Actuator
415 7027790 1 Sensor, Oil Pressure
416 to 417 Not Used
418 7020459 1 Thermostat
7020460 1 Spring, Compression
419 See Note 1 Flywheel (Not Shown) Note: Not Available for Purchase)
7024579 1 Rim, Gear (Not Shown)
420 7027245 1 Filter, Fuel
421 7027239 1 Solenoid, Start
FIGURE 2-10. DEUTZ ENGINE INSTALLATION (BELGIUM BUILT MACHINES S/N 1300000981
TO PRESENT & ROMANIAN BUILT MACHINES S/N E300000100 TO S/N E300001114)
ITEM # PART NUMBER QTY. DESCRIPTION REV.