JLG 3246E2 Operator Manual User Manual
Page 17
SECTION 2 - USER RESPONSIBILITIES, MACHINE PREPARATION, AND INSPECTION
3120854
– JLG Lift –
2-5
Figure 2-1. Daily Walk-Around Inspection - 2032E2/2632E2/2646E2/3246E2 (Sheet 2 of 2).
GENERAL
Begin the “Walk-Around Inspection” at Item 1, as noted
on the diagram. Continue Left (counterclockwise viewed
from top) checking each item in sequence for the condi-
tions listed in the following checklist.
TO AVOID POSSIBLE INJURY, BE SURE MACHINE POWER IS
“OFF” DURING “WALK-AROUND INSPECTION”.
DO NOT OVERLOOK VISUAL INSPECTION OF CHASSIS UNDER-
SIDE. CHECKING THIS AREA OFTEN RESULTS IN DISCOVERY
OF CONDITIONS WHICH COULD CAUSE EXTENSIVE MACHINE
DAMAGE.
NOTE: On each item, make sure there are no loose or
missing parts, that they are securely fastened, and
that no visible damage exists in addition to any
other criteria mentioned.
1.
Platform Control Console - Placard secure and
legible, control lever and switches return to neu-
tral, control lever lock and emergency stop switch
function properly, manual in storage box.
2.
Spindle, Tie Rod and Steer Linkage (left front) -
See Note
3.
Safety Prop - See Note
4.
Sizzor Arms and Sliding Wear Pads - See Note
5.
Wheel and Tire Assembly, Left Front - See Note
6.
Drive Cutout Switch - See Note
7.
Compartment Cover and Latches - See Note
8.
Ground Controls - Placard secure and legible,
control switches return to neutral position, emer-
gency stop switch functions properly. Control
markings legible.
9.
Hydraulic Reservoir - Recommended hydraulic
fluid level on level indicator on tank. Breather cap
secure and working.
10.
Hydraulic Filter - See Note
11.
Hydraulic Pump/Motor - See Note
12.
Pothole Protection System - See Note
13.
Hourmeter - See Note
14.
Wire Installation - See Note
15.
Control Valve Installation - No unsupported wires
or hoses; no damaged or broken wires.
16.
Wheel and Tire Assembly, Left Rear - See Note
17.
Drive Motor, Left Rear - See Note
18.
Sizzor Arms and Sliding Wear Pads - See Note
19.
Handle for Manual Descent (2646E2/3246E2) -
See Note
20.
Manual Descent Pump (2632E2/2646E2/3246E2) -
See Note
21.
Manual Descent (2032E2) - See Note
22.
Brake Cylinder - See Note
23.
Ladder - See Note
24.
Sizzor Arms and Sliding Wear Pads - See Note
25.
Drive Motor, Right Rear - See Note
26.
Wheel and Tire Assembly, Right Rear - See Note
27.
Lift Cylinder - See Note
28.
Tilt Switch - See Note
29.
Battery Compartment - Proper electrolyte level.
30.
Pothole Protection System - See Note
31.
Battery Charger - See Note
32.
Compartment Cover and Latches - See Note
33.
Wheel and Tire Assembly, Right Front - See Note
34.
Platform/Handrail Installation (Not Shown) - See
Note
35.
Sizzor Arms and Sliding Wear Pads - See Note