Battery Tender Power Pro Modular Marine Charger (PN 022-0179) User Instructions - Manual (Page 4)

7
STATUS INDICATOR LIGHTS: The following describes the
indicator light operation:
 NEITHER LIGHT TURNS ON (RED OR GREEN) – This is an abnormal
condition and most likely indicates that the charger is not properly
connected to the AC power.
 RED LIGHT FLASHING – The red light flashing indicates that the battery
charger has AC power available and that the microprocessor is functioning
properly. If the red light continues to flash, then either the battery voltage
is too low (less than 3 volts) or the ring terminals are not connected
correctly.
 RED LIGHT ON STEADY – Whenever the red light is on steady, a battery
is connected properly and the charger is charging the battery. The red
light will remain on until the charger completes the charging stage.
 GREEN LIGHT FLASHING – When the green light is flashing, and the red
light is on, the battery is greater than 80% charged and may be removed
from the charger and used if necessary. However, this is not a good idea
for deep cycle batteries. Whenever possible, leave the battery on charge
until the green light is solid.
 GREEN LIGHT ON STEADY – When the green light stops flashing and
burns steady, the charge is complete.
 ALTERNATING RED & GREEN LIGHTS FLASHING – This is abnormal
and most likely indicates that the battery is sulfated.
TROUBLESHOOTING CHECK LIST:
1. NEITHER OF THE CHARGER LIGHTS TURN ON AFTER THE AC POWER
PLUG IS CONNECTED TO THE AC ELECTRICAL OUTLET:
Check the
charger AC power plug connection at the AC electrical outlet. Verify that the AC
electrical outlet is functioning properly by plugging in another appliance or a
voltmeter.
2. THE CHARGER GREEN LIGHT GOES ON IMMEDIATELY WHEN AC
POWER IS APPLIED TO THE CHARGER:
The charger connections at the
battery may be intermittent, the battery may be defective, or the battery might already
be fully charged.
3. CHARGER IS CHARGING BUT THE GREEN LIGHT DOES NOT TURN ON
IN A REASONABLE AMOUNT OF TIME:
The battery may be large and requires
more time to fully charge than originally expected, there may be another appliance
drawing electric power from the battery while it is charging, or the battery may be
defective. Also, a newly purchased battery may not be fully charged and may take
longer to charge initially.
4. THE RED LIGHT COMES AGAIN AFTER THE GREEN LIGHT CAME ON.
There may be another appliance drawing electric power from the battery causing its
voltage to drop below the reset level. The battery charger then goes back into full
charge mode. Also, the charger connections at the battery may be intermittent or the
battery may be defective.
8
SPECIFICATION SUMMARY:
Technical Specifications 12V 5A 3 Bank (4 Bank)
Input Voltage / Frequency 120 VAC / 50 / 60 Hz
Max Input Current 6.0 (8.0) Arms @ 120 VAC
Output Current (Nominal) 5 Amps DC per Module
Output Voltage (Nominal) 12 Volts DC per Module
Charger Output Voltage Amplitudes throughout the entire
charge algorithm, including absorption and float maintenance,
are consistent with the optimum charging recommendations of
the major lead-acid battery manufacturers.
Maximum Operating Temperature 50
C (Nominal)
Charger Envelope Dimensions:
3 (4) Position Base Plate & Modular Units Installed
12L x 8W x 7H (15.5L x 8W x 7H)
Note: Allow an additional space for safe bend of AC and DC power
cord strain relief.
Shipping Weight:
Approx. 17.25 lbs (22.5
lbs)
WITH:
Accessories & Retail Packaging
Approximate Shipping Carton Dimensions Modular Unit (Base Plate):
8.5L x 6.25W x 4H (15.5L x 8W x 2H)
Declaration of Conformity: These battery charger products are
designed to meet the specific requirements of UL-1236 that are
applicable to this configuration.
Design Conformance & Revision: All charger products are 100%
inspected and electrically tested prior to shipment. All battery charger
designs are proprietary and subject to change without notice. Manufacturer
makes no specific claims nor does it either make or imply any specific
guarantee or warranty with respect to either the physical configuration or
performance of any of the battery charger products listed herein, including
suitability for purpose or merchantability.
DELTRAN CORPORATION
801 U.S. Highway 92 East
DeLand, Florida 32724
Phone 386-736-7900 FAX 386-736-0379
www.batterytender.com