Kifco T45x1320 400,000 - Present Operator Manual - Manual (Page 7)

Safety
Important recommendation with risk for the hosereel
User instruction book St8
3)
- Important
recommendations
for do
not damage:
the PE hose - 2) Attention to the sticky land:
- The winding must take place in the 24 Hours after the unwinding for
to avoid that the hose glues too much to ground, or if it rains on the extended
hose, it is strongly counseled to place log of wood to regular interval under the
tube before beginning the winding.
- 3) first winding:
- When conducted the first winding of the water-reel, it is important that the hose is completely
unwound, in order to be able to roll up the hose in a compact and regular on the hosedrum.
- 4) laxity of the hose on the hosedrum:
- Do not transport the water-reel with the raised anti-return pawl! The tube will slacken and probably
the spires will ride. Do not the starting up in such case.
- 5) Towing the water-reel:
- Never displace the water-reel if the hose was not previously and rolled up completely
on the hosedrum.
- 6) attention to the PE hose:
- Don't pass on the hose with some vehicle that it is, don't crush it and don't roll up it
around object
- 1) Always winding up the PE hose under pressure:
- The PE hose risks damage irreparably when a winding
with the power take off if enough pressure in the hose .
To prevent that him himself distort (elongation, flattent,
bend etc...). Use a nozzle plugged or with an hole of 1
or 2 mm for not to irrigate the land and to permit the
cooling of the pump.
Mechanism
- 7) winding with the power take off:
- when winding with the power take off, think about to stop winding when trolley arrive.
- 1) change gear:
- Never change gear or pulley rapport during winding or unwinding, always to stop. and push the hosedrum
on the non-return pawl change.
- 2) the anti-return pawl:
- Never low the anti-return pawl during the unwinding, only during the winding or when stopped.
- 3) the impeller of turbine:
- Attention do not inhale water too to charge in stone. Before beginning the winding let
some minutes from the moment where the conduct is put under pressure. It allows all
impurities or to some deposit is contained in the hose to be eliminated, without coming to damage,
the impeller of the turbine
- 4) PTO think about to stop tractor:
- Attention during winding with the power take off The hose retention bar doesn't stop winding that is to
the user to stop the tractor in time.
- 5) pressure and flow:
- Attention the pressure to inlet of the hosereel doesn't owe exeder 10 bar and flow:
- 50 m³/h for the turbine 10/50
- 130 m³/h for the turbine 25/130
Safety
Read serial number and model
User instruction book St8
4)
- Serial number
and
model
Water-reel model
S.R.L S.R.L CALENDASCO - PIACENZA - ITALY CALENDASCO - PIACENZA - ITALY
MOD./TYPE MOD./TYPE N. N.
DATA/DATE DATA/DATE
PE PE
PESO TOTALE VUOTO PESO TOTALE VUOTO
TOTAL WEIGHT EMPTY
TOTAL WEIGHT EMPTY
PESO TOTALE PIENO PESO TOTALE PIENO
TOTAL WEIGHT FULL
TOTAL WEIGHT FULL
LENGHT LENGHT
LUNG.
LUNG. Kg Kg
Kg Kg
ST 5 ST 5 467 467
18/10/2001 18/10/2001
100 100
340 340
Serial number Ø of PE hose
Length of PE hose
- In case of a problem on the reel, you may
be asked the model of hose-reel, the serial
number, the diameter and the length of the
hose.
Page 03