Retsch CryoMill Autofill 50l - Manual (Page 15)

Safety and occupational health instructions
15
This list is not complete.
Pos : 5.33 /00005 Ü berschriften/ 1.1.1 Ü bersc hriften/111 D ewar Empfehl ung en @ 0\mod_1233906148542_9.doc @ 5958 @ @ 1
3.5.3 Recommendations
Pos : 5.34 /00010 Bedi enungsanleitung en Kapitels ammlungen/Cr yoMill/0020 Cr yo Sic her heits kapitel/Cr yo Kapitel Kr yo Expl osi onsg efahr Empfehl ung @ 0\mod_1233907415909_9.doc @ 6092 @ @ 1
To avoid the danger of explosion:
• Always use suitable insulating lids (pay attention to waste gas opening).
• Observe filling levels to avoid the formation of ice on the insulating lid.
• Set up the vessel in dry and roofed rooms.
• Monitor atmospheric humidity in the installation room.
• Check vessel regularly for the collection of condensed water.
• Check vessel regularly for damage to surface or material damage
This list is not complete.
Pos : 5.35 /00005 Ü berschriften/1.1.1 Ü bersc hriften/111 D ewar Allgemeines Ver hal ten i m F alle ei nes U nfall es @ 0\mod_1233906662030_9.doc @ 5970 @ @ 1
3.5.4 General conduct in the case of an accident
Pos : 5.36 /00010 Bedi enungsanleitung en Kapitels ammlungen/Cr yoMill/0020 Cr yo Sic her heits kapitel/Cr yo Kapitel Kr yo Expl osi onsg efahr U nfall @ 0 \mod_1233907416394_9.doc @ 6099 @ @ 1
In the case of an accident from oxygen deficiency the following regulations should
be observed.
• Secure the surrounding area to avoid any subsequent accidents.
• Act quickly.
• The rescuers must take measures to protect themselves (respiratory
protection device).
• Move the injured persons from the hazardous area.
• Observe the company instructions for emergencies.
• Ventilate the rooms affected sufficiently.
• Investigate the cause of the accident.
This list is not complete.
Pos : 5.37 /00005 Ü berschriften/1.1 Ü bersc hriften/1.1 Übersc hriften Dewar/11 Dewar Sauers toffanr eicherung @ 0 \mod_1233752153835_9.doc @ 5716 @ @ 1
3.6 Oxygen enrichment
Pos : 5.38 /00005 Ü berschriften/1.1.1 Ü bersc hriften/111 D ewar Gefahr en @ 0\mod_1233906093088_9.doc @ 5946 @ @ 1
3.6.1 Dangers
Pos : 5.39 /00010 Bedi enungsanleitung en Kapitels ammlungen/Cr yoMill/0020 Cr yo Sic her heits kapitel/Cr yo Kapitel Kr yo Sauerstoffanr eicherung Gefahren @ 0 \mod_1233907417378_9.doc @ 6113 @ @ 1
Oxygen enrichment may increase the danger of explosion and fire.
Pos : 5.40 /00005 Ü berschriften/1.1.1 Ü bersc hriften/111 D ewar Urs ac hen @ 0\mod_1233906124198_9.doc @ 5952 @ @ 1
3.6.2 Causes
Pos : 5.41 /00010 Bedi enungsanleitung en Kapitels ammlungen/Cr yoMill/0020 Cr yo Sic her heits kapitel/Cr yo Kapitel Kr yo Sauerstoffanr eicherung Urs achen @ 0\mod_1233907417863_9.doc @ 6120 @ @ 1
Oxygen may be condensed from the air if liquid nitrogen is used and similarly be
liquefied because the boiling point of oxygen (approx. -183° C) is above that of
nitrogen (-196° C).
Pos : 5.42 /00005 Ü berschriften/1.1.1 Ü bersc hriften/111 D ewar Empfehl ung en @ 0\mod_1233906148542_9.doc @ 5958 @ @ 1
3.6.3 Recommendations
Pos : 5.43 /00010 Bedi enungsanleitung en Kapitels ammlungen/Cr yoMill/0020 Cr yo Sic her heits kapitel/Cr yo Kapitel Kr yo Sauerstoffanr eicherung Empfehlungen @ 0\mod_1233907418394_9.doc @ 6127 @ @ 1
The following points must be considered in the case of oxygen enrichment:
• Do not smoke.
• Where possible, keep easily inflammable materials away from the vessel.