Coleman 5600 - Manual (Page 37)

CAUTION
A collision with the grill, as with any metal object, could cause
injury. Use care when moving a portable gas grill.
WARNING
If the grill is not in use, the gas MUST be turned off at the fuel
supply cylinder.
Moving and Storage
Troubleshooting
DANGER
NEVER attempt to operate your grill without orifices in the valves.
A serious and immediate fire hazard would result.
• COOKING GRATES: Clean cooking grates with mild soap and hot
water. Remove stubborn residue with a mild cleanser or scrub brush.
Use a brass-bristle brush on porcelain-coated grates. DO NOT use a
commercial oven cleaner.
• PORCELAIN-COATED HEAT TENTS™: Wipe off grease residue
using a cleaning pad and a brass-bristle brush to knock off residue.
Use care not to damage porcelain finish. Replace heat tents to their
correct position.
• GRILL INTERIOR: Remove grates and porcelain heat tents.
Scrape side with tools and remove excess grease and cooking
residue.
Orifices
Valves
REPRESENTATIVE ILLUSTRATION
24
Problem: Burner will not light or has incomplete
burner flame.
Possible Causes and Solutions:
1. Make sure the 9-volt battery is fresh.
2. Check for spider webs or insect nest in venturi and clean venturi.
3. Lack of fuel. Check to see cylinder valve is open and cylinder
has fuel.
4. Misalignment of venturi on orifices. Position venturi over orifices.
5. Burner ports, orifices, valves or hose have blockage. Clean the
components.
6. If burner lights with match but not igniter, check ceramic elec-
trode position in gas collector and condition of igniter wire and
its connections. Perform igniter test and replace any damaged
parts.
7. Crimped fuel supply hose needs straightened.
8. Regulator failure or damaged hose need to be replaced by an
authorized service dealer.
9. Make sure hose to cylinder is properly assembled (pg. 32).
Problem: Yellow flame.
Possible Causes and Solutions:
1. Check for spider webs or insect nest in venturi and clean
venturi.
2. New burner may have residual oil which will burn off.
3. Clean off any food residue, grease or seasoning salts on
burner.
4. Air may be in cylinder if cylinder was not properly purged.
Use up remaining gas; the yellow flame may disappear
with use.
5. Venturi may be misaligned and needs to be lined up over orifice.
37
CAUTION
All cleaning and maintenance should be done only when grill is
cool & with the fuel supply turned off at the cylinder. If your
grill is set up for use with Natural Gas, turn off gas supply at
the system manual shut off valve.
Cleaning and Maintenance
Suggested Cleaning Materials:
• Mild dishwashing liquid detergent • Hot water • Wire brush
• Paper clip • Nylon cleaning pad • Soft brass-bristled brush
• Putty knife • Scraper
Component Cleaning:
• BURNER: Wire-brush loose corrosion from burner exterior.
Clean clogged gas port holes with an opened paper clip.
Replace corroded or damaged burners that would emit excess
gas.
• STAINLESS STEEL: Clean with any multipurpose (low abrasive,
no phosphorous) metal polish or stainless steel polish and a soft
cloth to prevent marring or scratching the surface. NEVER
USE OVEN CLEANER!
• ORIFICES: Unscrew orifices from rear of valves (Fig. 24). Wash
orifices in solvent and blow air through the small end holes.
Carefully replace the orifices in valve when they are dry. Make
certain that orifices are tightly reassembled.
Moving the grill:
• Move grill slowly. DO NOT run with or pull the grill behind you;
it could hit you from behind causing injury.
• DO NOT move the grill while it is lit or hot, or with objects on
the cooking surface(s) or side table(s).
After moving the grill:
• Check all gas connections for leaks that could occur from the
movement.
• Check the venturi tubes to be sure they are still over the ori-
fices.
Steps to follow before storing grill:
• Clean the grill.
• Coat the burner lightly with cooking oil to retard rusting.
• For outdoor use only. If grill is stored indoors, detach and
leave cylinder outdoors. If left outdoors, turn off the fuel supply
to the L.P. cylinder and cover the grill for protection from the
weather. Grill covers may be purchased from a grill dealer or
manufacturer.