Vortech 1987-1996 Ford 5.0L/5.8L Truck/SUV User Manual
Page 23
P/N: 4FC020-010
©2000 Vortech Engineering, Inc.
All Rights Reserved, Intl. Copr. Secured
13SEP00 V1.3
(86-93 5.0 Lt Truck(4FC))
16. FINAL CHECK
A. Reconnect the battery.
B. If your vehicle has gone over 10,000 miles
since its last spark plug change, you will
need to change the spark plugs now before
test driving the vehicle.
C. Check all fittings, nuts, bolts and clamps for
tightness. Pay particular attention to oil and
fuel lines around moving parts, sharp edges
and exhaust system parts. Make sure all
wires and lines are properly secured with
clamps or tie wraps.
D. Check all fluid levels, making sure that your
tank(s) is/are filled with 92 octane or higher
fuel before commencing test drive.
E. Start engine and allow to idle a few minutes,
then shut off.
F. Recheck to be sure that no hoses, wires, etc.
are near exhaust headers or moving parts
and for signs of any fluid leakage. Check
ignition timing to make sure it is set to stock
specifications before commencing test drive.
G. PLEASE TAKE SPECIAL NOTE: Operat-
ing the vehicle without ALL the subassem-
blies completely and properly installed may
cause FAILURE OF MAJOR COMPO-
NENTS.
H. Test drive the vehicle.
I.
The supercharger drive belt stretches ini-
tially and will require adjustment between
250 and 400 miles.
J.
Read the STREET SUPERCHARGER SYS-
TEM OWNER'S MANUAL AND RETURN
THE WARRANTY REGISTRATION FORM
within thirty (30) days of purchasing your
supercharger system to qualify.
WARNING: Do not attempt to operate
the vehicle until ALL
components are installed
and ALL operations are
completed including the
final check.
13