E-Z-GO 602080 - Manual (Page 32)

OPERATION AND SERVICE INFORMATION
Page 16 Owner’s Manual and Service Guide
Read all of manual to become thoroughly familiar with this vehicle. Pay particular attention to all Notes, Cautions and Warnings
** First occurrence only
#
More frequently in dusty conditions
To perform service that is listed in this schedule but not described in this manual, contact a local Service Representative
or see Repair and Service Manual for this vehicle.
Some maintenance items must be serviced more frequently on vehicles used under severe driving conditions.
BASIC SERVICE PARTS
To order parts, SERVICE PARTS Department contact
information is as follows:
In USA, Phone: 1-800-241-5855; Fax: 1-800-448-8124
Outside USA, Phone: 010-1-706-798-4311; Fax: 010-1-
706-771-4609
E-Z-GO Division of TEXTRON, Inc., 1451 Marvin Griffin
Road, Augusta, Georgia USA 30906-3852
ITEM
BEFORE
EACH
USE WEEKLY
EVERY
20
HOURS
EVERY
50
HOURS
EVERY
100
HOURS
EVERY
200
HOURS
EVERY
300
HOURS
EVERY
500
HOURS
Tie Rods/Linkages Check X
Rear Axle Check X** X
Replace X
Muffler/Exhaust Check X
Spark Arrester Clean X
Front Axle Check X** X
Front Knuckles Check X
Front Struts Check X
Front Wheel Alignment Check X
Rear Shock Absorbers Check X
Fuel Tank Clean X
Throttle/Governor Linkage Check X
Hardware And Fasteners Check X
Tighten X
Battery Clean X
Drive Belt Check X
Front Wheel Bearings Check X
Drive shafts Lubricate X
C.V.Joints and Boots Check X
Fig. 21 Periodic Service Schedule
Air Filter Element 72944-G01
Oil Filter 15400-POH-305PE
Spark Plugs
ZGR5A (NGK)
J16CR-U (DENSO)
Optional Alternator Belt 73561-G01
CVT Belt 73965-G01
Fuse
15 amp (P/N 35212-G01)
20 amp (P/N 35212-G02)
7.5 amp (P/N 35212-G05)
Headlight Bulb 20209-G3
Tail Light Bulb #1157 (P/N 21759-G1)
Fig. 22 Basic Service Parts