Document Outline

• ШЁжтлл^
  • A WARNING
    • INTRODUCTION
      • A WARNING
    • IMPORTANT NOTICE
      • A SAFETY INFORMATION
    • FOR THE PARENTS
      • A SAFETY INFORMATION
    • CONTENTS
    • GENERAL INFORMATION
      • MACHINE
      • IDENTIFICATION
        • VEHICLE IDENTIFICATION NUMBER
        • NOTE:
          • ENGINE SERIAL NUMBER
        • NOTE:
      • CONTROL FUNCTIONS
        • A WARNING
          • "ENGINE STOP" SWITCH
          • FRONT BRAKE LEVER
          • REAR BRAKE PEDAL
          • STARTER LEVER (CHOKE)
        • ▲WARNING
          • FUEL TANK CAP
          • Do not overfill the fuel tank. Avoid spilling fuel on the hot engine.
        • FUEL AND OIL
          • FUEL
          • ENGINE OIL (OIL TANK)
          • TRANSMISSION OIL
        • NOTE:
          • NOTE:
      • PRE-OPERATION CHECKS
        • A WARNING
          • If any item in the PRE-OPERATION CHECK is not working properly, have it inspected and repaired before operating the machine.
          • BRAKE (FRONT AND REAR)
          • WHEEL
          • TIRES
          • THROTTLE GRIP
          • "ENGINE STOP" SWITCH
          • FITTINGS/FASTENERS
      • STARTING AND OPERATION
        • CAUTION:
          • Prior to operating the machine, perform steps listed in pre-operation check list.
          • A WARNING
          • STARTING A COLD ENGINE
      • AWARNING
        • Before starting the engine, be sure to shift the transmission into neutral.
        • STARTING A WARM ENGINE
        • CAUTION:
          • WARMING UP
          • A WARNING
          • Before starting off, be sure to turn up or remove the side stand.
          • ENGINE BREAK-IN
    • PERIODIC MAINTENANCE AND ADJUSTMENT
      • MAINTENANCE AND LUBRICATION SCHEDULE CHART
      • Lubrication intervals
      • Periodic maintenance intervals
      • SERVICE NOTES:
      • SPECIAL TOOLS
        • FOR ENGINE SERVICE
        • FOR CHASSIS SERVICE
        • FOR ELECTRICAL SERVICE
      • ADJUSTMENT
        • A WARNING
          • SPARK PLU^
          • NOTE:
          • IGNITION TIMING CHECKING
          • AIR FILTER CLEANING
        • CAUTION:
        • CAUTiON:
        • CAUTiON:
        • NOTE:
          • THROTTLE CABLE ADJUSTMENT
          • NOTE:
          • AUTOLUBE PUMP
          • NOTE:
          • FRONT BRAKE ADJUSTMENT
          • REAR BRAKE ADJUSTMENT
          • TIRE PRESSURE CHECK
          • CHECK THE SPOKES
          • STEERING HEAD INSPECTION
          • STEERING HEAD ADJUSTMENT
          • NOTE:
          • FRONT FORK OIL CHANGE
        • A WARNING
          • 2. Support the machine securely so there is no danger of it falling over.
          • NOTE:
          • REAR SHOCK ABSORBER (MONOCROSS SUSPENSION "DE CARBON" SYSTEM)
        • A WARNING
          • This shock absorber contains highly compressed nitrogen gas.
        • CAUTiOM;
        • A WARNING
    • MAINTENANCE AND MINOR REPAIRS
      • PREPARATION FOR SERVICE
        • Inspection
        • Adjustment
        • CAUTION:
          • Check the needle valve and valve seat for wear before adjustment.
          • Inspection
          • MUFFLER
      • ^WARNING
        • Be sure the exhaust pipe and muffler are cool before cleaning the spark arrester.
        • Removal
      • ^WARNING
        • TOP END
        • NOTE:
        • NOTE:
          • Maintenance
        • NOTE:
          • Removal
        • NOTE:
          • Inspection
        • NOTE:
          • KICK STARTER Removal
          • Inspection
          • Reassembly
          • SHIFTER
        • NOTE:
          • Inspection
          • Removal
      • CHASSIS
        • FRONT WHEEL Removal
        • REAR WHEEL Removal
        • Installation
        • A WARNING
        • Always use a new cotter pin.
        • BRAKE SHOE INSPECTION
        • BRAKE DRUM INSPECTION
        • TIRE
        • Inspection
        • CAUTION:
          • Always use a cloth to avoid cutting your hand.
          • Reassembly
          • REPLACING WHEEL BEARINGS
          • CHECKING RIM
          • REAR SHOCK ABSORBER (MONOCROSS SUSPENSION)
          • SWINGARM INSPECTION
          • LUBRICATION OF LEVER, PEDALS, ETC.
          • CABLE INSPECTION AND LUBRICATION
          • THROTTLE CABLE AND GRIP LUBRICATION
    • MISCELLANEOUS
      • ELECTRICAL COMPONENTS AND WIRING DIAGRAM
        • ELECTRICAL COMPONENTS
      • WIRING DIAGRAM
        • TROUBLESHOOTIIMG
        • "ENGINE STOP" SWITCH INSPECTION
        • IGNITION COIL INSPECTION
        • CDI MAGNETO INSPECTION
        • TROUBLESHOOTING
      • CLEANING AND STORAGE
        • Cleaning
      • CAUTION:
        • NOTE:
          • Storage
        • NOTE:
          • General
      • SPECIFICATIONS
        • Engine
        • Chassis
        • Tightening Torque
        • Electrical
        • TORQUE SPECIFICATIONS
      • CABLE ROUTING
      • NOISE REGULATION.
        • TAMPERING WITH NOISE CONTROL SYSTEM PROHIBITED:
      • MAINTENANCE RECORD