Modine Manufacturing 6-558.6 User Manual
Warning, Caution
WARNING
Improper installation, adjustment, alteration, service or
maintenance can cause property damage, injury or death,
and could cause exposure to substances which have been
determined by various state agencies to cause cancer, birth
defects or other reproductive harm. Read the installation,
operating and maintenance instructions thoroughly before
installing or servicing this equipment.
6-558.6
P/N 5H72256A Rev. F
INSTALLATION AND SERVICE MANUAL
separated combustion
high efficiency
gas-fired unit heaters
models PSH & BSH
Contents
Page
Inspection on arrival . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Performance data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Dimensional data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Checking input rate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Propeller heaters. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
Service instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Troubleshooting guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
Motor data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Control options . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
Rating plate identification . . . . . . . . . . . . . . . . . . . . . . . . . 27
Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Back cover
FOR YOUR SAFETY
If you smell gas:
1. Open windows
2. Don't touch electrical switches.
3. Extinguish any open flame.
4. Immediately call your gas supplier.
FOR YOUR SAFETY
The use and storage of gasoline or other flammable vapors
and liquids in open containers in the vicinity of this appliance
is hazardous.
THIS MANUAL IS THE PROPERTY OF THE OWNER.
PLEASE BE SURE TO LEAVE IT WITH THE OWNER WHEN
YOU LEAVE THE JOB.
All models approved for use in California by the CEC (when
equipped with IPI), in New York by the MEA division, and in
Massachusetts. Unit heater is certified for non-residential
applications.
CAUTION
To prevent premature heat exchanger failure do not locate
ANY gas-fired units in areas where chlorinated, halogenated
or acid vapors are present in the atmosphere.
Inspection on Arrival
1.
Inspect unit upon arrival. In case of damage, report
immediately to transportation company and your local
Modine sales representative.
2.
Check rating plate on unit to verify that power supply meets
available electric power at the point of installation.
3.
Inspect unit received for conformance with description of
product ordered (including specifications where applicable).
October, 2002