Superior SSBV-3530CNM - Manual (Page 7)

NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.
7
Figure 7
Firebox
Top
Lintel Securing Screw
Hole in Cabinet Top
Scoop Securing Screws
Scoop
WARNING
Do not operate the shutoff lever
unless a complete outside COM-
BUSTION air system has been
installed with your appliance.
Outside Combustion Air Controls
Figure 8
Spill Switch (limit disc)
Bracket Securing Screws
Firebox
Top
Lintel Securing Screw
Hole in Cabinet Top
Spill Switch (limit disc)
View Without Scoop
Many appliances are equipped, when installed,
with an outside (make-up air) vent system that
is designed to provide the appliance with outside
make-up air for combustion when in operation.
The combustion air control lever for the outside
air system is standard on all appliances but
should not be operated if the complete system
is not installed. Refer to Figures 9 & 10. When
the complete outside air vent system is installed,
the installer will remove the securing screw from
the combustion air control lever located on the
left side of the fireplace bottom opening.
If the securing screw has not been removed
and you have reason to believe that you have
a complete outside air system, contact your
distributor to have your appliance inspected for
the presence of the complete system. DO NOT
assume that you have this system in place.
Operate the actuator through several cycles
including the closed position. Ensuring proper
operation and freedom of movement. Return
the actuator arm to the closed position.
Figure 10
Outside Air Control Lever and Securing
Screw Location on Left Side of Cabinet
in Lower Control Compartment Area
Outside Air Control Lever
Outside Air Control Lever
Outside Air Control Lever
Securing Screw Removed
Air Shutter in
Closed Position
Air Shutter in
Open Position
Outside Air Control Lever
Securing Screw
WARNING
Handle this glass with extreme
care! Tempered glass is suscep-
tible to damage – do not scratch
or handle roughly while rein-
stalling the glass door frame.
Front Glass Enclosure Panel, Removal
and Installation
WARNING
Do not operate appliance with the
glass front removed, cracked or
broken. Replacement of the glass
should be done by a licensed or
qualified service technician.
WARNING
Do not attempt to substitute the
materials used on this door, or
replace cracked or broken glass
with any materials other than
those provided by the appliance
manufacturer.
WARNING
Do not attempt to touch the front
enclosure glass with your hands
while the fireplace is in use.
Figure 9
To open the outside air shutter, remove the bottom
louvered control comartement door, reach into
control compartment and pull the combustion air
control lever all the way out. The outside air shutter
should be fully open when the fireplace is in use
and completely closed when the fireplace is not
being used. Closing it when not in use will prevent
outside cold air from entering the dwelling.
WARNING
The glass door must only be
replaced as a complete unit as pro-
vided by the manufacturer. Do not
attempt to replace broken, cracked
or chipped glass separately.
These are B-Vent appliances. They are designed
to operate only when the front glass enclosure
panel is installed. Generally the front glass
enclosure panel should not be removed except to
gain access to the components within the firebox,
and the appliance may only be operated without
the front glass enclosure panel in place for very
brief periods of time during appliance checkout
and adjustment. Note: The flame appearance
will be diminished and appear smaller than
normal while the front glass enclosure panel
is removed.
During this appliance checkout and adjust-
ment period, a potential safety hazard exists
- EXERCISE EXTREME CAUTION to prevent
the occurrence of any burn injuries from the
exposed flames or hot surfaces.
Figure 11 - INSTALLING GLASS DOOR
Top Flange on
Glass Door
Bottom
Vee-flange
Glass Door
Glass
Door
Latch
Glass Door
Firebox
Floor
WARNING
This appliance may only be fitted
with doors certified for use with
the appliance.
AVERTISSEMENT
Pour utilisation uniquement avec
les portes en verre certifiêes avec
l'appareil .