Land Pride RTR1042 - Manual (Page 2)

Table of Contents
RTR10 & RTR15 Series Rotary Tillers 311-431M 11/01/11
© Copyright 2011 All rights Reserved
Land Pride provides this publication “as is” without warranty of any kind, either expressed or implied. While every precaution has been taken in the
preparation of this manual, Land Pride assumes no responsibility for errors or omissions. Neither is any liability assumed for damages resulting from the use
of the information contained herein. Land Pride reserves the right to revise and improve its products as it sees fit. This publication describes the state of this
product at the time of its publication, and may not reflect the product in the future.
Land Pride is a registered trademark.
All other brands and product names are trademarks or registered trademarks of their respective holders.
Printed in the United States of America.
Important Safety Information . . . . . . . . . . . . . 1
Safety at All Times . . . . . . . . . . . . . . . . . . . . . . . . . 1
Look For The Safety Alert Symbol . . . . . . . . . . . . . 1
Safety Labels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Application . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Using This Manual . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Terminology . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Definitions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Owner Assistance . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Serial Number . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Further Assistance . . . . . . . . . . . . . . . . . . . . . . . . 9
Section 1: Assembly & Set-Up . . . . . . . . . . . 10
Dealer Preparations . . . . . . . . . . . . . . . . . . . . . . . 10
Tractor Requirements . . . . . . . . . . . . . . . . . . . . . . 10
Torque Requirements . . . . . . . . . . . . . . . . . . . . . . 10
Parking Stand . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
3-Point Hitch Assembly . . . . . . . . . . . . . . . . . . . . . 11
Front Deflector . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Rear Deflector Assembly . . . . . . . . . . . . . . . . . . . . 12
Tractor Hook-Up . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Driveline Installation . . . . . . . . . . . . . . . . . . . . . . . 13
Check Driveline Collapsible Length . . . . . . . . . . 14
Shorten Driveline . . . . . . . . . . . . . . . . . . . . . . . . 14
Check Driveline Maximum Length . . . . . . . . . . . 15
Check Driveline Interference . . . . . . . . . . . . . . . 15
Section 2: Operating . . . . . . . . . . . . . . . . . . . 16
Operating Checklist . . . . . . . . . . . . . . . . . . . . . . . . 16
Inspections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Safety Information . . . . . . . . . . . . . . . . . . . . . . . . . 16
Transporting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Parking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
General Operating Notes . . . . . . . . . . . . . . . . . . . . 18
General Operating Instructions . . . . . . . . . . . . . . . 19
Section 3: Adjustments . . . . . . . . . . . . . . . . . 20
RTR10 Tiller Hitch Offset . . . . . . . . . . . . . . . . . . . . 20
RTR15 Tiller Hitch Sideshift . . . . . . . . . . . . . . . . . . 20
Drive Chain . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Rear Deflector . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Skid Shoe Adjustment . . . . . . . . . . . . . . . . . . . . . . 22
Section 4: Maintenance & Lubrication . . . . . 23
Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Tine Replacement . . . . . . . . . . . . . . . . . . . . . . . . . 23
Driveline Protection . . . . . . . . . . . . . . . . . . . . . . . . 23
Clutches With 4 Adjusting Nuts . . . . . . . . . . . . . . . 23
Clutch Run-In . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Clutch Disassembly & Assembly . . . . . . . . . . . . 24
Clutches With 8 Hex Socket Bolts . . . . . . . . . . . . . 25
Clutch Run-In . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Clutch Disassembly & Assembly . . . . . . . . . . . . 25
Shearbolt Protection . . . . . . . . . . . . . . . . . . . . . . . 25
Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
Lubrication . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
Driveline U-Joint . . . . . . . . . . . . . . . . . . . . . . . . . 26
Driveline Shaft . . . . . . . . . . . . . . . . . . . . . . . . . . 26
Chaincase . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
Bearing On Right End Of Rotor Shaft . . . . . . . . . 27
Gearbox . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
Section 5: Specifications & Capacities . . . . . 28
RTR10 Series Rotary Tiller . . . . . . . . . . . . . . . . . 28
RTR15 Series Rotary Tiller . . . . . . . . . . . . . . . . . 29
Section 6: Features & Benefits . . . . . . . . . . . 30
RTR10 Series Rotary Tiller . . . . . . . . . . . . . . . . . 30
RTR15 Series Rotary Tiller . . . . . . . . . . . . . . . . . 31
Section 7: Troubleshooting . . . . . . . . . . . . . . 32
Section 8: Torque Values Chart . . . . . . . . . . 33
Section 9: Warranty . . . . . . . . . . . . . . . . . . . . 35
Table of Contents